HelpForCars.net- All Aobut Automotive Repairs
HelpForCars.net- All Aobut Automotive Repairs
TSB
 
GMC
 
SIERRA
 
2004

Technical Service Bulletins for 2004 GMC SIERRA

Bulletin Number: SB-080604003-C Bulletin Date: 09-01-2014
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary
Gmc/chevrolet: engines, with egr system, has leakage from egr cooler engine coolant into the combustion chamber. model 2002-15 silverado, sierra, 2004-09 kodiak c4500-c5500, topkick c4500-c5500, 2006-15 express, savana. *pe
Bulletin Number: SB-080604003-C Bulletin Date: 09-01-2014
Component:
Engine (pws)
Summary
Gmc/chevrolet: engines, with egr system, has leakage from egr cooler engine coolant into the combustion chamber. model 2002-15 silverado, sierra, 2004-09 kodiak c4500-c5500, topkick c4500-c5500, 2006-15 express, savana. *pe
Bulletin Number: UIB-117 Bulletin Date: 07-16-2014
Component:
061000 engine and engine cooling:engine
Summary
General motors: an optional engine block heater plug in for onboard ac power and with continuous usage will result in shorting of wires, over heating system, electrical failure and compartment engine fires. model 2003-15 express cut away
Bulletin Number: PI-0011A Bulletin Date: 06-01-2013
Component:
171100 latches/locks/linkages:doors:latch
Summary
Gm: the front or rear door may not open from the inside or outside handle, the door will not unlock with any method. the probably cause an incorrect installation of a handle component. *rm updated on 7/26/2013. all 2014 and prior gm pass
Bulletin Number: PIP-4290 Bulletin Date: 02-01-2013
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary
Engine surge or stall at stop and/or dtc p0742 possible tcc applied. equipped with allison lct1000 transmission rpo m74 or mw7. *nj updated 4/22/13. *pe
Bulletin Number: 09-09-40-001A Bulletin Date: 01-01-2012
Component:
150000 seat belts
Summary
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin Number: 09-09-40-001A Bulletin Date: 01-01-2012
Component:
151600 seat belts:front:warning light/devices
Summary
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/
Bulletin Number: SB-10240 Bulletin Date: 01-01-2012
Component:
353600 equipment:air conditioner
Summary
General motors service campaign: see document search button for owner letter. the hvac blower may not work at certain functions or may become inoperable. there could be a burning smell or smoke. *rm updated 4/6/12. *pe
Bulletin Number: PIP-3366-B Bulletin Date: 11-01-2011
Component:
Power train:automatic transmission
Summary
Cadillac/chevrolet/gmc/hummer: some suvs and trucks are exhibiting a condition where by grinding/ratcheting type noise coming from automatic transmission when shifting into park while in 4wd low (4lo) range. *pe
Bulletin Number: PIP-3366-B Bulletin Date: 11-01-2011
Component:
103000 power train:automatic transmission
Summary
Cadillac/chevrolet/gmc/hummer: some suvs and trucks are exhibiting a condition where by grinding/ratcheting type noise coming from automatic transmission when shifting into park while in 4wd low (4lo) range. *pe
Bulletin Number: PIP-4492P Bulletin Date: 05-01-2011
Component:
Engine and engine cooling:engine
Summary
Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/
Bulletin Number: PIP-4492P Bulletin Date: 05-01-2011
Component:
Engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary
Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/
Bulletin Number: SB-10240 Bulletin Date: 05-01-2011
Component:
Equipment:electrical:air conditioner
Summary
General motors service campaing: see document search button for owner letter. the hvac blower may not work at certain functions or may become inoperable. there could be a burning smell or smoke. *rm
Bulletin Number: PIP-4492P Bulletin Date: 05-01-2011
Component:
061000 engine and engine cooling:engine
Summary
Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/
Bulletin Number: PIP-4492P Bulletin Date: 05-01-2011
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary
Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/
Bulletin Number: 50232008 Bulletin Date: 04-01-2011
Component:
Steering:hydraulic power assist:pump
Summary
Gear box power steering pump, p/s performance concerns. *nj updated on 6/30/2011. *kb
Bulletin Number: 50232008 Bulletin Date: 04-01-2011
Component:
015100 steering:hydraulic power assist:pump
Summary
Gear box power steering pump, p/s performance concerns. *nj updated on 6/30/2011. *kb
Bulletin Number: PIP-4851 Bulletin Date: 03-01-2011
Component:
Engine and engine cooling:engine
Summary
Gm: there is an intermittent engine light on due to five possible internal trouble codes. there may also be an extended crank after filling the fuel tank. *rm updated 5/31/11. *pe updated on 06/16/2011. *kb updated a second time
Bulletin Number: PIP-4851 Bulletin Date: 03-01-2011
Component:
061000 engine and engine cooling:engine
Summary
Gm: there is an intermittent engine light on due to five possible internal trouble codes. there may also be an extended crank after filling the fuel tank. *rm updated 5/31/11. *pe updated on 06/16/2011. *kb updated a second time
Bulletin Number: 09-09-40-001A Bulletin Date: 02-01-2011
Component:
Seat belts
Summary
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm
Bulletin Number: 09-09-40-001A Bulletin Date: 02-01-2011
Component:
Seat belts:front:warning light/devices
Summary
Gm: there are seat belt problems: difficulty latching and unlatching buckle. buckle release button is sticking. seat belt warning light illuminated. likely caused by sticky beverages that are spilled into the buckle assembly. *rm
Bulletin Number: 10-00-89-017C Bulletin Date: 02-01-2011
Component:
Unknown or other
Summary
Gm: information on fixing multiple situations right the first time. *rm
Bulletin Number: PI-0011A Bulletin Date: 02-01-2011
Component:
Latches/locks/linkages:doors:latch
Summary
Gm: the front or rear door may not open from the inside or outside handle, the door will not unlock with any method. the probably cause an incorrect installation of a handle component. *rm
Bulletin Number: 10-00-89-017C Bulletin Date: 02-01-2011
Component:
980000 unknown or other
Summary
Gm: information on fixing multiple situations right the first time. *rm
Bulletin Number: PIP-4138K Bulletin Date: 01-01-2011
Component:
Engine and engine cooling
Summary
Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm
Bulletin Number: PIP-4138K Bulletin Date: 01-01-2011
Component:
060000 engine and engine cooling
Summary
Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm
Bulletin Number: PIP-3504C Bulletin Date: 11-01-2010
Component:
Engine and engine cooling:engine:diesel
Summary
Gm: there is a diesel engine hard start when hot. starts fine when cold. there will be no internal trouble codes. *rm
Bulletin Number: PIT-3749D Bulletin Date: 11-01-2010
Component:
Structure:frame and members
Summary
Gm: on some truck models there is some frame corrosion. *rm
Bulletin Number: PIP-3504C Bulletin Date: 11-01-2010
Component:
061200 engine and engine cooling:engine:diesel
Summary
Gm: there is a diesel engine hard start when hot. starts fine when cold. there will be no internal trouble codes. *rm
Bulletin Number: SB-10-02-33-001 Bulletin Date: 10-01-2010
Component:
Steering
Summary
Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
Bulletin Number: SB-10-02-33-001 Bulletin Date: 10-01-2010
Component:
Steering:gear box:shaft pitman
Summary
Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
Bulletin Number: SB-10-02-33-001 Bulletin Date: 10-01-2010
Component:
010000 steering
Summary
Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
Bulletin Number: SB-10-02-33-001 Bulletin Date: 10-01-2010
Component:
013200 steering:gear box:shaft pitman
Summary
Buick/cadillac/chevrolet/gmc/oldsmobile and hummer: information on pitman arm shaft seal service kit. do not replace entire steering gear for pitman seal leak. technicians have been replacing entire steering gears due to not being able to
Bulletin Number: 4039 Bulletin Date: 12-01-2009
Component:
Fuel system, gasoline:fuel injection system:injectors
Summary
Chevroletgmc service campaign: see document search button for owner letter. special policy adjustment - injectors - replace. *mj updated 2/21/08. *nj csc letter was received. updated 3/5/10. *pe
Bulletin Number: 3630 Bulletin Date: 07-01-2009
Component:
Fuel system, other:storage:fuel gauge system
Summary
Inaccurate fuel gauge readings/rear float arm stuck. *tt updated 03-01-07. *kb updated 3/15/10. *pe
Bulletin Number: 3630 Bulletin Date: 07-01-2009
Component:
091200 fuel system, other:storage:fuel gauge system
Summary
Inaccurate fuel gauge readings/rear float arm stuck. *tt updated 03-01-07. *kb updated 3/15/10. *pe
Bulletin Number: 3187 Bulletin Date: 06-01-2009
Component:
Engine and engine cooling
Summary
Engine low power will not go over 2300 rpms. *eh updated 6/11/10. *pe
Bulletin Number: 3187 Bulletin Date: 06-01-2009
Component:
060000 engine and engine cooling
Summary
Engine low power will not go over 2300 rpms. *eh updated 6/11/10. *pe
Bulletin Number: 30525007 Bulletin Date: 05-01-2009
Component:
Service brakes, hydraulic:antilock
Summary
Antilock brake (abs) activation at low speeds (clean wheel speed sensor mounting surface). *tt updated 10/23/09. *pe
Bulletin Number: PIP-4629 Bulletin Date: 04-01-2009
Component:
Engine and engine cooling:engine:diesel
Summary
Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe
Bulletin Number: PIP-4629 Bulletin Date: 04-01-2009
Component:
Engine and engine cooling:engine:other fuel types:turbo-charger
Summary
Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe
Bulletin Number: PIP-4629 Bulletin Date: 04-01-2009
Component:
061200 engine and engine cooling:engine:diesel
Summary
Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe
Bulletin Number: PIP-4629 Bulletin Date: 04-01-2009
Component:
061320 engine and engine cooling:engine:other fuel types:turbo-charger
Summary
Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe
Bulletin Number: 3317 Bulletin Date: 12-01-2008
Component:
Engine and engine cooling
Summary
Hard start / no start outside temperatures below freezing. *tt updated 7/13/09. *pe
Bulletin Number: 3317 Bulletin Date: 12-01-2008
Component:
060000 engine and engine cooling
Summary
Hard start / no start outside temperatures below freezing. *tt updated 7/13/09. *pe
Bulletin Number: 08089-B Bulletin Date: 11-01-2008
Component:
Electrical system
Summary
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin Number: 08089-B Bulletin Date: 11-01-2008
Component:
Equipment:electrical:navigational system(global positioning system)
Summary
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin Number: 08089-B Bulletin Date: 11-01-2008
Component:
Electrical system: software
Summary
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin Number: 08089-B Bulletin Date: 11-01-2008
Component:
110000 electrical system
Summary
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin Number: 08089-B Bulletin Date: 11-01-2008
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin Number: 08089-B Bulletin Date: 11-01-2008
Component:
118000 electrical system: software
Summary
General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe
Bulletin Number: PIT-4722 Bulletin Date: 10-01-2008
Component:
Power train:automatic transmission:cooling unit and lines
Summary
Gmc: fluid leak from transmission oil cooler lines due to corrosion. all 2000-2006 light duty trucks equipped with the light duty automatic transmission. *pe
Bulletin Number: PIT-4722 Bulletin Date: 10-01-2008
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary
Gmc: fluid leak from transmission oil cooler lines due to corrosion. all 2000-2006 light duty trucks equipped with the light duty automatic transmission. *pe
Bulletin Number: PIT3504D Bulletin Date: 09-05-2008
Component:
Equipment:other:owners/service/other manual
Summary
Some customers may comment on various hvac concerns including temperature doors defaulting to full hot position or unable to obtain defrost position. *pe
Bulletin Number: PIT3504D Bulletin Date: 09-05-2008
Component:
355200 equipment:other:owners/service/other manual
Summary
Some customers may comment on various hvac concerns including temperature doors defaulting to full hot position or unable to obtain defrost position. *pe
Bulletin Number: 7187 Bulletin Date: 09-01-2008
Component:
Digital instrument panel
Summary
Cadillacchevroletgmc service campaign: see document search button for owner letter. instrument panel cluster gauge needle function may cause inaccurate readings on some 2003-2004 cadillac, chevrolet, and gmc vehicles. *nj updated 2/5
Bulletin Number: 07187A Bulletin Date: 09-01-2008
Component:
Digital instrument panel
Summary
Cadillacchevroletgmc service campaign: see document search button for owner letter. some vehicles could develop a condition where one or more of the instrument panel gauge needles may stick, flutter, or become inoperative. csc letter
Bulletin Number: 7187 Bulletin Date: 09-01-2008
Component:
117000 digital instrument panel
Summary
Cadillacchevroletgmc service campaign: see document search button for owner letter. instrument panel cluster gauge needle function may cause inaccurate readings on some 2003-2004 cadillac, chevrolet, and gmc vehicles. *nj updated 2/5
Bulletin Number: 07187A Bulletin Date: 09-01-2008
Component:
117000 digital instrument panel
Summary
Cadillacchevroletgmc service campaign: see document search button for owner letter. some vehicles could develop a condition where one or more of the instrument panel gauge needles may stick, flutter, or become inoperative. csc letter
Bulletin Number: PIT-3046E Bulletin Date: 08-01-2008
Component:
Fuel system, other:storage:fuel gauge system
Summary
Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe
Bulletin Number: PIT-3046E Bulletin Date: 08-01-2008
Component:
091200 fuel system, other:storage:fuel gauge system
Summary
Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe
Bulletin Number: 08-089 Bulletin Date: 06-01-2008
Component:
Equipment:electrical
Summary
Buickcadillacchevroletgmchummeroldsmobilepontiacsaabsaturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
Bulletin Number: 08-089 Bulletin Date: 06-01-2008
Component:
353000 equipment:electrical
Summary
Buickcadillacchevroletgmchummeroldsmobilepontiacsaabsaturn service campaign: see document search button for owner letter. special coverage adjustment-analog onstar deactivation. fcc ruled in 2002 wireless carriers would no longer r
Bulletin Number: 3009 Bulletin Date: 05-01-2008
Component:
Suspension
Summary
Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08. *pe
Bulletin Number: 8136 Bulletin Date: 05-01-2008
Component:
Fuel system, other:storage:fuel gauge system
Summary
Chevroletgmc service campaign: see document search button for owner letter. on-board diagnostics (obd)-fuel level sender-reprogram engine control module (ecm). csc was received. *pe
Bulletin Number: 3009 Bulletin Date: 05-01-2008
Component:
020000 suspension
Summary
Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08. *pe
Bulletin Number: 8136 Bulletin Date: 05-01-2008
Component:
091200 fuel system, other:storage:fuel gauge system
Summary
Chevroletgmc service campaign: see document search button for owner letter. on-board diagnostics (obd)-fuel level sender-reprogram engine control module (ecm). csc was received. *pe
Bulletin Number: 05-06-04-047 Bulletin Date: 04-01-2008
Component:
Engine and engine cooling:engine
Summary
Service engine soon (ses) light on with reduction in engine power, diagnostic trouble codes p0202 and p2146 or p0207 and p2149 set. *tt add dtc p1294. install revised 90 degree injector connector with harness support bracket servi
Bulletin Number: 000235003N Bulletin Date: 04-01-2008
Component:
Steering:column
Summary
Clunking noise under hood and can be felt in steering wheel and/or steering column (replace upper intermediate steering shaft [i-shaft] assembly). *pe
Bulletin Number: 08-07-30-015 Bulletin Date: 04-01-2008
Component:
Power train:automatic transmission
Summary
Diagnostic information on mn8, mt1 ses/mil illuminated, dtc p0757, harsh shift, delayed 2-3 shift, 2-3 shift flare, no third gear, slips in third gear or reverse. *pe
Bulletin Number: 05-06-04-047 Bulletin Date: 04-01-2008
Component:
061000 engine and engine cooling:engine
Summary
Service engine soon (ses) light on with reduction in engine power, diagnostic trouble codes p0202 and p2146 or p0207 and p2149 set. *tt add dtc p1294. install revised 90 degree injector connector with harness support bracket servi
Bulletin Number: 000235003N Bulletin Date: 04-01-2008
Component:
012000 steering:column
Summary
Clunking noise under hood and can be felt in steering wheel and/or steering column (replace upper intermediate steering shaft [i-shaft] assembly). *pe
Bulletin Number: 08-07-30-015 Bulletin Date: 04-01-2008
Component:
103000 power train:automatic transmission
Summary
Diagnostic information on mn8, mt1 ses/mil illuminated, dtc p0757, harsh shift, delayed 2-3 shift, 2-3 shift flare, no third gear, slips in third gear or reverse. *pe
Bulletin Number: 7057 Bulletin Date: 02-01-2008
Component:
Engine and engine cooling:engine:diesel
Summary
Chevroletgmc service campaign: see document search button for owner letter. special coverage adjustment - engine glow plug on certain vehicles with 6.6l diesel v8 (rpo lb7 - vin 1) engine & california emissions (yf5/ne1) or clean fuel emis
Bulletin Number: PIP3394 Bulletin Date: 02-01-2008
Component:
Power train:automatic transmission:control module (tcm, pcm)
Summary
Duramax diesel injector driver codes with 6.6 engine (vin 2 - rpo lly). *nj
Bulletin Number: PIP3343 Bulletin Date: 02-01-2008
Component:
Engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary
Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj
Bulletin Number: PIP4054A Bulletin Date: 02-01-2008
Component:
Suspension:rear
Summary
Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe
Bulletin Number: 7057 Bulletin Date: 02-01-2008
Component:
061200 engine and engine cooling:engine:diesel
Summary
Chevroletgmc service campaign: see document search button for owner letter. special coverage adjustment - engine glow plug on certain vehicles with 6.6l diesel v8 (rpo lb7 - vin 1) engine & california emissions (yf5/ne1) or clean fuel emis
Bulletin Number: PIP3394 Bulletin Date: 02-01-2008
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary
Duramax diesel injector driver codes with 6.6 engine (vin 2 - rpo lly). *nj
Bulletin Number: PIP3343 Bulletin Date: 02-01-2008
Component:
063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
Summary
Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj
Bulletin Number: PIP4054A Bulletin Date: 02-01-2008
Component:
022000 suspension:rear
Summary
Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe
Bulletin Number: 05-04-21-003 Bulletin Date: 01-01-2008
Component:
Power train:transfer case (4-wheel drive)
Summary
Service 4wd light illuminated, diagnostic trouble code (dtc) c0374 set. *tt updated 10/05/07. *nj inspect wiring harness to transfer case speed sensors, replace wiring harness. updated 7/18/08 *pe
Bulletin Number: 05-04-21-003 Bulletin Date: 01-01-2008
Component:
104000 power train:transfer case (4-wheel drive)
Summary
Service 4wd light illuminated, diagnostic trouble code (dtc) c0374 set. *tt updated 10/05/07. *nj inspect wiring harness to transfer case speed sensors, replace wiring harness. updated 7/18/08 *pe
Bulletin Number: 4290 Bulletin Date: 12-01-2007
Component:
Power train:automatic transmission:control module (tcm, pcm)
Summary
Engine surge or stall at stop and/or dtc p0742 possible tcc applied. equipped with allison lct1000 transmission rpo m74 or mw7. *nj
Bulletin Number: 3061 Bulletin Date: 12-01-2007
Component:
Power train:automatic transmission:control module (tcm, pcm)
Summary
Dtc c0327 with or without additional dtc's setting. with four wheel drive (4wd) only. *nj
Bulletin Number: 3061 Bulletin Date: 12-01-2007
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary
Dtc c0327 with or without additional dtc's setting. with four wheel drive (4wd) only. *nj
Bulletin Number: 70842013 Bulletin Date: 09-01-2007
Component:
Exterior lighting:turn signal:flasher unit
Summary
Turn signal in camper style outside rearview mirror (rpo dpn) does not illuminate turn signal flash (replace upper mirror glass) *nj
Bulletin Number: 70842013 Bulletin Date: 09-01-2007
Component:
126100 exterior lighting:turn signal:flasher unit
Summary
Turn signal in camper style outside rearview mirror (rpo dpn) does not illuminate turn signal flash (replace upper mirror glass) *nj
Bulletin Number: 40232001 Bulletin Date: 08-01-2007
Component:
Steering
Summary
Release of steering gear stub shaft bearing kit for service. *tt updated 08-15-07. *kb updated 10/09/07. *nj
Bulletin Number: 40232001 Bulletin Date: 08-01-2007
Component:
010000 steering
Summary
Release of steering gear stub shaft bearing kit for service. *tt updated 08-15-07. *kb updated 10/09/07. *nj
Bulletin Number: 30309002 Bulletin Date: 07-01-2007
Component:
Suspension
Summary
Rear leaf spring slap or clunk noise (replace spring inserts) *tt updated 10/18/07. *nj
Bulletin Number: 40525002 Bulletin Date: 06-01-2007
Component:
Service brakes, air:antilock:abs warning light
Summary
Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb
Bulletin Number: 40525002 Bulletin Date: 06-01-2007
Component:
046400 service brakes, air:antilock:abs warning light
Summary
Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb
Bulletin Number: 70601009 Bulletin Date: 05-01-2007
Component:
Engine and engine cooling:engine:diesel
Summary
Diesel engine cylinder head gasket missing thickness grade markings. *kb
Bulletin Number: 70601009 Bulletin Date: 05-01-2007
Component:
061200 engine and engine cooling:engine:diesel
Summary
Diesel engine cylinder head gasket missing thickness grade markings. *kb
Bulletin Number: 30604030 Bulletin Date: 03-01-2007
Component:
Engine and engine cooling:engine
Summary
Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
Bulletin Number: 235003 Bulletin Date: 02-01-2007
Component:
Steering
Summary
Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated. *kb
Bulletin Number: 235003 Bulletin Date: 02-01-2007
Component:
010000 steering
Summary
Clunking noise under hood and can be felt in steering wheel. *eh updated *eh updated. *kb
Bulletin Number: 10310010 Bulletin Date: 01-01-2007
Component:
Suspension
Summary
Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns. *kb
Bulletin Number: 10310010 Bulletin Date: 01-01-2007
Component:
020000 suspension
Summary
Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns. *kb
Bulletin Number: 40604001 Bulletin Date: 12-01-2006
Component:
Engine and engine cooling:engine
Summary
Various intermittent driveability conditions - hesitation, lack of power, etc. *tt
Bulletin Number: 60604026 Bulletin Date: 12-01-2006
Component:
Engine and engine cooling:engine
Summary
Intermittent ses/mil lamp illuminated, reduced engine power, fuel injector driver circuit. dtc's p0201, p0202, p0203, p0204, p0205, p0206, p0207, p0208. cylinder bank shut down dtc's p2146, or p2149. *kb
Bulletin Number: 60417002 Bulletin Date: 12-01-2006
Component:
Suspension:rear:axle:non-powered axle assembly
Summary
Rear drive axle whine noise (replace slip yoke assembly). *kb
Bulletin Number: 40604001 Bulletin Date: 12-01-2006
Component:
061000 engine and engine cooling:engine
Summary
Various intermittent driveability conditions - hesitation, lack of power, etc. *tt
Bulletin Number: 60604026 Bulletin Date: 12-01-2006
Component:
061000 engine and engine cooling:engine
Summary
Intermittent ses/mil lamp illuminated, reduced engine power, fuel injector driver circuit. dtc's p0201, p0202, p0203, p0204, p0205, p0206, p0207, p0208. cylinder bank shut down dtc's p2146, or p2149. *kb
Bulletin Number: 60417002 Bulletin Date: 12-01-2006
Component:
022520 suspension:rear:axle:non-powered axle assembly
Summary
Rear drive axle whine noise (replace slip yoke assembly). *kb
Bulletin Number: 50138012 Bulletin Date: 11-01-2006
Component:
Equipment:electrical:air conditioner
Summary
Ei05082 - loss of blower motor speeds except for high speed or inoperative. *tt updated. *kb updated *kb
Bulletin Number: 50138012 Bulletin Date: 11-01-2006
Component:
353600 equipment:air conditioner
Summary
Ei05082 - loss of blower motor speeds except for high speed or inoperative. *tt updated. *kb updated *kb
Bulletin Number: 4150 Bulletin Date: 10-11-2006
Component:
Fuel system, other:storage:fuel gauge system
Summary
Dual tanks fuel gauge defaults to empty - new calibrations. stall start tank transfer. vehicles with 6.6l rpo lb7 or lly engines. *kb
Bulletin Number: 4150 Bulletin Date: 10-11-2006
Component:
091200 fuel system, other:storage:fuel gauge system
Summary
Dual tanks fuel gauge defaults to empty - new calibrations. stall start tank transfer. vehicles with 6.6l rpo lb7 or lly engines. *kb
Bulletin Number: 3227 Bulletin Date: 10-04-2006
Component:
Structure:body:tailgate
Summary
Tailgate cable slack. this includes 1998-2006 chevrolet and gmc full and mid size trucks. *eh updated. *kb
Bulletin Number: 3227 Bulletin Date: 10-04-2006
Component:
162500 structure:body:tailgate
Summary
Tailgate cable slack. this includes 1998-2006 chevrolet and gmc full and mid size trucks. *eh updated. *kb
Bulletin Number: 40604007 Bulletin Date: 10-01-2006
Component:
Engine and engine cooling:engine
Summary
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt
Bulletin Number: 30604036 Bulletin Date: 10-01-2006
Component:
Engine and engine cooling
Summary
Information on servicing fuel injectors to avoid contamination. *eh updated 03-19-07. *kb
Bulletin Number: 40604007 Bulletin Date: 10-01-2006
Component:
061000 engine and engine cooling:engine
Summary
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt
Bulletin Number: 30604036 Bulletin Date: 10-01-2006
Component:
060000 engine and engine cooling
Summary
Information on servicing fuel injectors to avoid contamination. *eh updated 03-19-07. *kb
Bulletin Number: 3927 Bulletin Date: 09-27-2006
Component:
Power train:automatic transmission
Summary
Engine with a repeat cracked flywheel. *kb
Bulletin Number: 3713 Bulletin Date: 09-27-2006
Component:
Visibility:power window devices and controls
Summary
Door glass pops out of run channel. *kb
Bulletin Number: 3927 Bulletin Date: 09-27-2006
Component:
103000 power train:automatic transmission
Summary
Engine with a repeat cracked flywheel. *kb
Bulletin Number: 3713 Bulletin Date: 09-27-2006
Component:
133000 visibility:power window devices and controls
Summary
Door glass pops out of run channel. *kb
Bulletin Number: 3340 Bulletin Date: 09-23-2006
Component:
Suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
Summary
Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb
Bulletin Number: 3340 Bulletin Date: 09-23-2006
Component:
021244 suspension:front:springs:leaf spring assembly:u-bolt, leaf spring to axle
Summary
Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb
Bulletin Number: 20730004 Bulletin Date: 09-01-2006
Component:
Power train:automatic transmission
Summary
New product information, grade brake feature of allison 1000 series transmission. *slc this bulletin replaces 02-07-30-004. *tt
Bulletin Number: 30693001 Bulletin Date: 05-01-2006
Component:
Engine and engine cooling:engine
Summary
Diagnostic information on turbocharger malfunction due to lack of engine oil for lbz, lb7, and lly duramax diesel engine. *kb
Bulletin Number: 30693001 Bulletin Date: 05-01-2006
Component:
061000 engine and engine cooling:engine
Summary
Diagnostic information on turbocharger malfunction due to lack of engine oil for lbz, lb7, and lly duramax diesel engine. *kb
Bulletin Number: 60308002 Bulletin Date: 03-01-2006
Component:
Suspension:front:control arm:upper arm
Summary
Revised upper control arm replacement. *tt
Bulletin Number: 60308002 Bulletin Date: 03-01-2006
Component:
021510 suspension:front:control arm:upper arm
Summary
Revised upper control arm replacement. *tt
Bulletin Number: 030730031D Bulletin Date: 02-01-2006
Component:
Power train:automatic transmission
Summary
Transmission leaks, slips, vehicle will not move. *tt
Bulletin Number: 50730017 Bulletin Date: 02-01-2006
Component:
Power train:automatic transmission
Summary
4l60-e/4l65-e automatic transmission/torque converter clutch (tcc) shudder, water in transmission. *tt
Bulletin Number: 50730017 Bulletin Date: 02-01-2006
Component:
103000 power train:automatic transmission
Summary
4l60-e/4l65-e automatic transmission/torque converter clutch (tcc) shudder, water in transmission. *tt
Bulletin Number: 30850014 Bulletin Date: 01-01-2006
Component:
Electrical system
Summary
Intermittent no start, service stability message, anti-lock brake system (abs) light illuminated, multiple diagnostic trouble codes (dtcs), dic shows unknown driver, various electrical related conditions. includes escalade esv and ext mod
Bulletin Number: 60601003 Bulletin Date: 01-01-2006
Component:
Engine and engine cooling:engine
Summary
Information on longer main bearing cap bolts required for certain 2001-2006 lb7, lly, lbz duramax diesel engines. *tt
Bulletin Number: 60232001 Bulletin Date: 01-01-2006
Component:
Steering
Summary
Increased steering and brake effort. *tt
Bulletin Number: 60601003 Bulletin Date: 01-01-2006
Component:
061000 engine and engine cooling:engine
Summary
Information on longer main bearing cap bolts required for certain 2001-2006 lb7, lly, lbz duramax diesel engines. *tt
Bulletin Number: 60232001 Bulletin Date: 01-01-2006
Component:
010000 steering
Summary
Increased steering and brake effort. *tt
Bulletin Number: 50604077 Bulletin Date: 12-01-2005
Component:
Engine and engine cooling:engine
Summary
Lack of power lu3 engine) at high ambient temperatures only (if necessary, reprogram pcm with new service calibration).*ak
Bulletin Number: 50604077 Bulletin Date: 12-01-2005
Component:
061000 engine and engine cooling:engine
Summary
Lack of power lu3 engine) at high ambient temperatures only (if necessary, reprogram pcm with new service calibration).*ak
Bulletin Number: 030605008B Bulletin Date: 11-01-2005
Component:
Engine and engine cooling:exhaust system
Summary
Advance service information - exhaust system popping/snapping noise when vehicle is hot, at idle or immediately after vehicle is shut off. *tt bulletin 03-06-05-008, dated 11/01/2003 replaced. *tt
Bulletin Number: 040525002B Bulletin Date: 11-01-2005
Component:
Service brakes, hydraulic:antilock:control unit/module
Summary
Anti-lock brake system (abs) light on, diagnostic trouble codes (dtcs) c0265, c0201, u1041 set and/or loss of communication with brake module. *tt update. *tt
Bulletin Number: 50849026 Bulletin Date: 11-01-2005
Component:
Engine and engine cooling
Summary
Low oil pressure message display and chimes activated while driving following hybrid (hp2) lm7 engine auto-start (reprogram the pcm). *ts
Bulletin Number: 50601034 Bulletin Date: 11-01-2005
Component:
Engine and engine cooling
Summary
Engine oil leak at rear cover assembly area. *tt
Bulletin Number: 040525002B Bulletin Date: 11-01-2005
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary
Anti-lock brake system (abs) light on, diagnostic trouble codes (dtcs) c0265, c0201, u1041 set and/or loss of communication with brake module. *tt update. *tt
Bulletin Number: 50849026 Bulletin Date: 11-01-2005
Component:
060000 engine and engine cooling
Summary
Low oil pressure message display and chimes activated while driving following hybrid (hp2) lm7 engine auto-start (reprogram the pcm). *ts
Bulletin Number: 50601034 Bulletin Date: 11-01-2005
Component:
060000 engine and engine cooling
Summary
Engine oil leak at rear cover assembly area. *tt
Bulletin Number: 010730038B Bulletin Date: 10-01-2005
Component:
Power train:automatic transmission
Summary
The service engine soon lamp is illuminated, no 3rd and 4th gear, the transmission does not shift correctly, the transmission feels like it shifts to neutral or a loss of drive occurs. *tt
Bulletin Number: 040604007E Bulletin Date: 10-01-2005
Component:
Engine and engine cooling:engine
Summary
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt
Bulletin Number: 50604063 Bulletin Date: 10-01-2005
Component:
Engine and engine cooling:engine
Summary
Lm7, l59 or l33 engines with cold start rough or incorrect idle, misfire, malfunction indicator lamp (mil) or flashing requiring o2 sensor replacement. *tt
Bulletin Number: 50850012 Bulletin Date: 10-01-2005
Component:
Seats
Summary
Unwanted/loose seat movement. *tt
Bulletin Number: 040604007E Bulletin Date: 10-01-2005
Component:
061000 engine and engine cooling:engine
Summary
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt
Bulletin Number: 50604063 Bulletin Date: 10-01-2005
Component:
061000 engine and engine cooling:engine
Summary
Lm7, l59 or l33 engines with cold start rough or incorrect idle, misfire, malfunction indicator lamp (mil) or flashing requiring o2 sensor replacement. *tt
Bulletin Number: 50850012 Bulletin Date: 10-01-2005
Component:
220000 seats
Summary
Unwanted/loose seat movement. *tt
Bulletin Number: 30310006 Bulletin Date: 09-01-2005
Component:
Suspension
Summary
Reference guide for the technician to upgrade a vehicle from factory wheels and tires to 20 inch wheels and tires, which are available through gmspo. *tt
Bulletin Number: 050846006A Bulletin Date: 09-01-2005
Component:
Equipment
Summary
Information on upgrading certain onstar generation 5 analog/digital-ready systems to onstar generation 6 dual-mode (analog/digital). *tt
Bulletin Number: 30310006 Bulletin Date: 09-01-2005
Component:
020000 suspension
Summary
Reference guide for the technician to upgrade a vehicle from factory wheels and tires to 20 inch wheels and tires, which are available through gmspo. *tt
Bulletin Number: 30310006 Bulletin Date: 09-01-2005
Component:
020000 suspension
Summary
Reference guide for the technician to upgrade a vehicle from factory wheels and tires to 20 inch wheels and tires, which are available through gmspo. *tt
Bulletin Number: 050846006A Bulletin Date: 09-01-2005
Component:
350000 equipment
Summary
Information on upgrading certain onstar generation 5 analog/digital-ready systems to onstar generation 6 dual-mode (analog/digital). *tt
Bulletin Number: 020730024A Bulletin Date: 08-01-2005
Component:
Power train:automatic transmission:lever and linkage:column shift
Summary
Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt
Bulletin Number: 030693001A Bulletin Date: 08-01-2005
Component:
Engine and engine cooling:engine:diesel
Summary
Diagnostic information for turbo failure due to lack of oil or repeat turbo failures. *tt
Bulletin Number: 040850016B Bulletin Date: 08-01-2005
Component:
Seats
Summary
Memory seat may not return to requested position. *eh
Bulletin Number: 40604070 Bulletin Date: 08-01-2005
Component:
Engine and engine cooling:engine
Summary
Information on the revised fuel filter for the 6.6l duramax diesel. *tt
Bulletin Number: 708 Bulletin Date: 08-01-2005
Component:
Seats:front assembly:seat heater/cooler
Summary
Heated seats turn off. *sc
Bulletin Number: 5546 Bulletin Date: 08-01-2005
Component:
Equipment:other:owners/service/other manual
Summary
Program bulletin (customer satisfaction program)-15,000 mile (24,000 km) fuel filter change. 2002 chevrolet kodiak and 2001-2002 gmc topkick. *sc
Bulletin Number: 50850008 Bulletin Date: 08-01-2005
Component:
Seats:front assembly:seat heater/cooler
Summary
Intermittent heated seats inoperative, diagnostic trouble code b3941 set. *tt
Bulletin Number: 040850016B Bulletin Date: 08-01-2005
Component:
220000 seats
Summary
Memory seat may not return to requested position. *eh
Bulletin Number: 40604070 Bulletin Date: 08-01-2005
Component:
061000 engine and engine cooling:engine
Summary
Information on the revised fuel filter for the 6.6l duramax diesel. *tt
Bulletin Number: 708 Bulletin Date: 08-01-2005
Component:
221700 seats:front assembly:seat heater/cooler
Summary
Heated seats turn off. *sc
Bulletin Number: 5546 Bulletin Date: 08-01-2005
Component:
355200 equipment:other:owners/service/other manual
Summary
Program bulletin (customer satisfaction program)-15,000 mile (24,000 km) fuel filter change. 2002 chevrolet kodiak and 2001-2002 gmc topkick. *sc
Bulletin Number: 50850008 Bulletin Date: 08-01-2005
Component:
221700 seats:front assembly:seat heater/cooler
Summary
Intermittent heated seats inoperative, diagnostic trouble code b3941 set. *tt
Bulletin Number: 40602006 Bulletin Date: 06-01-2005
Component:
Engine and engine cooling:engine
Summary
Engine overheating. *tt
Bulletin Number: 50604029 Bulletin Date: 06-01-2005
Component:
Engine and engine cooling:engine
Summary
Flexible fuel (rpo l59) rough idle, misfire, malfunction indicator lamp diagnostic trouble code p0300. *tt
Bulletin Number: 509610018 Bulletin Date: 06-01-2005
Component:
Engine and engine cooling
Summary
Accessory drive belt chirp, squeal, or squeak type noise at cold idle. *tt
Bulletin Number: 40602006 Bulletin Date: 06-01-2005
Component:
061000 engine and engine cooling:engine
Summary
Engine overheating. *tt
Bulletin Number: 50604029 Bulletin Date: 06-01-2005
Component:
061000 engine and engine cooling:engine
Summary
Flexible fuel (rpo l59) rough idle, misfire, malfunction indicator lamp diagnostic trouble code p0300. *tt
Bulletin Number: 509610018 Bulletin Date: 06-01-2005
Component:
060000 engine and engine cooling
Summary
Accessory drive belt chirp, squeal, or squeak type noise at cold idle. *tt
Bulletin Number: 50730013 Bulletin Date: 05-01-2005
Component:
Power train:automatic transmission
Summary
4l60-e/4l65-e automatic transmission second gear start, lack/loss of power when accelerating from a stop. *tt
Bulletin Number: 50601014 Bulletin Date: 05-01-2005
Component:
Engine and engine cooling:engine
Summary
Oil leak under extreme cold temperatures (-34 degrees c) (-30 degrees f) or colder). *tt
Bulletin Number: 50730013 Bulletin Date: 05-01-2005
Component:
103000 power train:automatic transmission
Summary
4l60-e/4l65-e automatic transmission second gear start, lack/loss of power when accelerating from a stop. *tt
Bulletin Number: 50601014 Bulletin Date: 05-01-2005
Component:
061000 engine and engine cooling:engine
Summary
Oil leak under extreme cold temperatures (-34 degrees c) (-30 degrees f) or colder). *tt
Bulletin Number: 50604008 Bulletin Date: 04-01-2005
Component:
Engine and engine cooling:engine
Summary
Diagnostic trouble code (dtc) p1172 or p2636, fuel gauge reads empty, service engine soon (ses) light on. *tt
Bulletin Number: 50310005 Bulletin Date: 04-01-2005
Component:
Wheels
Summary
Handling characteristics of vehicles with 20 inch wheel/tire assemblies installed. *tt
Bulletin Number: 50604008 Bulletin Date: 04-01-2005
Component:
061000 engine and engine cooling:engine
Summary
Diagnostic trouble code (dtc) p1172 or p2636, fuel gauge reads empty, service engine soon (ses) light on. *tt
Bulletin Number: 50310005 Bulletin Date: 04-01-2005
Component:
200000 wheels
Summary
Handling characteristics of vehicles with 20 inch wheel/tire assemblies installed. *tt
Bulletin Number: 3102005 Bulletin Date: 03-10-2005
Component:
Steering
Summary
Steering gear whistle noise on turns. *eh
Bulletin Number: 3102005 Bulletin Date: 03-10-2005
Component:
010000 steering
Summary
Steering gear whistle noise on turns. *eh
Bulletin Number: 20307002 Bulletin Date: 03-01-2005
Component:
Suspension
Summary
Revised front caster and camber adjustment procedure. original not yet received. *tt
Bulletin Number: 50603001 Bulletin Date: 03-01-2005
Component:
Engine and engine cooling
Summary
Revised engine electrical and automatic transmission - 4l60e/4l65e subsections - new caution statements added. *tt
Bulletin Number: 50604021 Bulletin Date: 03-01-2005
Component:
Engine and engine cooling:exhaust system:emission control
Summary
Revised inspection/maintenance (i/m) evaporative emission (evap) system set procedure. *tt
Bulletin Number: 50604023 Bulletin Date: 03-01-2005
Component:
Engine and engine cooling
Summary
Revised diagnostic trouble code (dtc) p2563. *tt
Bulletin Number: 50604024 Bulletin Date: 03-01-2005
Component:
Engine and engine cooling
Summary
Revised diagnostic trouble code (dtc) p1172 and dtc p2636. *tt
Bulletin Number: 50604025 Bulletin Date: 03-01-2005
Component:
Engine and engine cooling
Summary
Revised diagnostic trouble code (dtc) u2104. *tt
Bulletin Number: 20307002 Bulletin Date: 03-01-2005
Component:
020000 suspension
Summary
Revised front caster and camber adjustment procedure. original not yet received. *tt
Bulletin Number: 50603001 Bulletin Date: 03-01-2005
Component:
060000 engine and engine cooling
Summary
Revised engine electrical and automatic transmission - 4l60e/4l65e subsections - new caution statements added. *tt
Bulletin Number: 50604021 Bulletin Date: 03-01-2005
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary
Revised inspection/maintenance (i/m) evaporative emission (evap) system set procedure. *tt
Bulletin Number: 50604023 Bulletin Date: 03-01-2005
Component:
060000 engine and engine cooling
Summary
Revised diagnostic trouble code (dtc) p2563. *tt
Bulletin Number: 50604024 Bulletin Date: 03-01-2005
Component:
060000 engine and engine cooling
Summary
Revised diagnostic trouble code (dtc) p1172 and dtc p2636. *tt
Bulletin Number: 50604025 Bulletin Date: 03-01-2005
Component:
060000 engine and engine cooling
Summary
Revised diagnostic trouble code (dtc) u2104. *tt
Bulletin Number: 702 Bulletin Date: 02-01-2005
Component:
Engine and engine cooling:engine
Summary
Duramax air filter. gm tech links. *tt
Bulletin Number: 502118002 Bulletin Date: 02-01-2005
Component:
Steering
Summary
Diagnostic trouble code c0455, service rear wheel steering, system jumps from 4-wheel steer to 2-wheel steer. *tt
Bulletin Number: 702 Bulletin Date: 02-01-2005
Component:
061000 engine and engine cooling:engine
Summary
Duramax air filter. gm tech links. *tt
Bulletin Number: 502118002 Bulletin Date: 02-01-2005
Component:
010000 steering
Summary
Diagnostic trouble code c0455, service rear wheel steering, system jumps from 4-wheel steer to 2-wheel steer. *tt
Bulletin Number: 020601022C Bulletin Date: 01-01-2005
Component:
Engine and engine cooling:engine
Summary
Information on engine ticking. including 2004 chevrolet kodiak c45/c5500 series and 2004 gmc topkick c4500/c5500 series. *tt update. *tt
Bulletin Number: 020526001B Bulletin Date: 01-01-2005
Component:
Service brakes, air
Summary
Rear parking brake shoe retaining spring clip service kit for drum-in-hat (dih) equipped vehicles. *tt update. *tt
Bulletin Number: 50090001 Bulletin Date: 01-01-2005
Component:
Engine and engine cooling
Summary
Information on the proper air filter for the duramax diesel. *eh
Bulletin Number: 502118001 Bulletin Date: 01-01-2005
Component:
Steering
Summary
Quadrasteer intermittent service 4-wheel steer message. *tt
Bulletin Number: 508132001 Bulletin Date: 01-01-2005
Component:
Equipment
Summary
Accessory power outlet (apo) turns off automatically - parallel hybrid truck (rpo hp2). *tt
Bulletin Number: 50730002 Bulletin Date: 01-01-2005
Component:
Power train:automatic transmission
Summary
New essential tool j 45096 23 automatic transmission oil cooler line adapter for allison transmission. *eh
Bulletin Number: 701 Bulletin Date: 01-01-2005
Component:
Fuel system, other
Summary
Fuel filter replacement. gm tech link. *tt
Bulletin Number: 50090001 Bulletin Date: 01-01-2005
Component:
060000 engine and engine cooling
Summary
Information on the proper air filter for the duramax diesel. *eh
Bulletin Number: 502118001 Bulletin Date: 01-01-2005
Component:
010000 steering
Summary
Quadrasteer intermittent service 4-wheel steer message. *tt
Bulletin Number: 508132001 Bulletin Date: 01-01-2005
Component:
350000 equipment
Summary
Accessory power outlet (apo) turns off automatically - parallel hybrid truck (rpo hp2). *tt
Bulletin Number: 50730002 Bulletin Date: 01-01-2005
Component:
103000 power train:automatic transmission
Summary
New essential tool j 45096 23 automatic transmission oil cooler line adapter for allison transmission. *eh
Bulletin Number: 701 Bulletin Date: 01-01-2005
Component:
090000 fuel system, other
Summary
Fuel filter replacement. gm tech link. *tt
Bulletin Number: 40731006 Bulletin Date: 12-01-2004
Component:
Power train
Summary
Excessive shifter and/or engine vibration, bearing growl and/or rattle type noise while depressing or releasing clutch pedal. *tt
Bulletin Number: 40731006 Bulletin Date: 12-01-2004
Component:
100000 power train
Summary
Excessive shifter and/or engine vibration, bearing growl and/or rattle type noise while depressing or releasing clutch pedal. *tt
Bulletin Number: 4056 Bulletin Date: 11-16-2004
Component:
Wheels
Summary
20 inch plus size wheel restriction - supplement to accessories bulletin acc04-056. gm voicemail express. *tt
Bulletin Number: 4056 Bulletin Date: 11-16-2004
Component:
200000 wheels
Summary
20 inch plus size wheel restriction - supplement to accessories bulletin acc04-056. gm voicemail express. *tt
Bulletin Number: 020846010E Bulletin Date: 11-01-2004
Component:
Unknown or other
Summary
Programming onstar module for canadian french voice recognition. *tt update. *tt updated *eh
Bulletin Number: 020601023C Bulletin Date: 11-01-2004
Component:
Engine and engine cooling
Summary
Oil leak at cooler to engine block mating surface. *eh
Bulletin Number: 020601023C Bulletin Date: 11-01-2004
Component:
060000 engine and engine cooling
Summary
Oil leak at cooler to engine block mating surface. *eh
Bulletin Number: 10292004 Bulletin Date: 10-29-2004
Component:
Engine and engine cooling:engine:gasoline:turbo-charger
Summary
This is in regards to the unnecessary changing of turbochargers due to oil seepage. *tt
Bulletin Number: 10292004 Bulletin Date: 10-29-2004
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary
This is in regards to the unnecessary changing of turbochargers due to oil seepage. *tt
Bulletin Number: 04007A Bulletin Date: 10-22-2004
Component:
Structure:body:tailgate
Summary
Tailgate support cable. recall 04007a. gm parts bulletins & information. *tt updated *eh
Bulletin Number: 04007A Bulletin Date: 10-22-2004
Component:
162500 structure:body:tailgate
Summary
Tailgate support cable. recall 04007a. gm parts bulletins & information. *tt updated *eh
Bulletin Number: 10192004 Bulletin Date: 10-19-2004
Component:
Wheels
Summary
20 inch plus wheels are no longer to be installed on this body style. *eh
Bulletin Number: 10192004 Bulletin Date: 10-19-2004
Component:
200000 wheels
Summary
20 inch plus wheels are no longer to be installed on this body style. *eh
Bulletin Number: 040089020A Bulletin Date: 10-01-2004
Component:
Unknown or other
Summary
Pre-delivery and service guide - parallel hybrid truck. *tt updated *eh
Bulletin Number: 40604065 Bulletin Date: 10-01-2004
Component:
Fuel system, other:storage:fuel gauge system
Summary
Engineering investigation (ei #04073) high, low or erratic oil pressure gauge reading setting diagnostic trouble codes p0522 and/or p0523. 2004 isuzu w4 also included. *tt update. *tt
Bulletin Number: 040523001A Bulletin Date: 10-01-2004
Component:
Service brakes, hydraulic
Summary
Low brake pedal, red brake light on, brake system warning message on. *tt updated *eh
Bulletin Number: 040525005A Bulletin Date: 10-01-2004
Component:
Service brakes, air:antilock:abs warning light
Summary
Antilock brake system light on service brake system message on driver information center. *eh updated *eh
Bulletin Number: 40138013 Bulletin Date: 10-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Hvac not cold enough a/c compressor does not engage . *eh
Bulletin Number: 40138014 Bulletin Date: 10-01-2004
Component:
Equipment:electrical:air conditioner
Summary
High pitched tone heard inside vehicle when ac compressor is engaged. *eh
Bulletin Number: 610 Bulletin Date: 10-01-2004
Component:
Structure:body
Summary
Rattle type noise coming from the rear of the cab during body twist maneuvers or over bumps. gm tech link. *tt
Bulletin Number: 040089020A Bulletin Date: 10-01-2004
Component:
980000 unknown or other
Summary
Pre-delivery and service guide - parallel hybrid truck. *tt updated *eh
Bulletin Number: 40604065 Bulletin Date: 10-01-2004
Component:
091200 fuel system, other:storage:fuel gauge system
Summary
Engineering investigation (ei #04073) high, low or erratic oil pressure gauge reading setting diagnostic trouble codes p0522 and/or p0523. 2004 isuzu w4 also included. *tt update. *tt
Bulletin Number: 040523001A Bulletin Date: 10-01-2004
Component:
030000 service brakes, hydraulic
Summary
Low brake pedal, red brake light on, brake system warning message on. *tt updated *eh
Bulletin Number: 040525005A Bulletin Date: 10-01-2004
Component:
046400 service brakes, air:antilock:abs warning light
Summary
Antilock brake system light on service brake system message on driver information center. *eh updated *eh
Bulletin Number: 40138013 Bulletin Date: 10-01-2004
Component:
353600 equipment:air conditioner
Summary
Hvac not cold enough a/c compressor does not engage . *eh
Bulletin Number: 40138014 Bulletin Date: 10-01-2004
Component:
353600 equipment:air conditioner
Summary
High pitched tone heard inside vehicle when ac compressor is engaged. *eh
Bulletin Number: 610 Bulletin Date: 10-01-2004
Component:
162000 structure:body
Summary
Rattle type noise coming from the rear of the cab during body twist maneuvers or over bumps. gm tech link. *tt
Bulletin Number: 9132004 Bulletin Date: 09-13-2004
Component:
Engine and engine cooling
Summary
Rough idle with white smoke and high balance rates. a 1700 1800 light throttle combustion noise. parking lot surge under ten miles per hour with engine rpm around 800 to 1000 rpm. this also includes 2004 3500 trucks with 6.6 liter diesel en
Bulletin Number: 9132004 Bulletin Date: 09-13-2004
Component:
060000 engine and engine cooling
Summary
Rough idle with white smoke and high balance rates. a 1700 1800 light throttle combustion noise. parking lot surge under ten miles per hour with engine rpm around 800 to 1000 rpm. this also includes 2004 3500 trucks with 6.6 liter diesel en
Bulletin Number: 010310010C Bulletin Date: 09-01-2004
Component:
Suspension
Summary
Inspection of tire and wheel size prior to diagnosis of transmission shifts, poor performance, speedometer, cruise control concerns. bulletin 01-03-10-010b not received. *tt
Bulletin Number: 030419001A Bulletin Date: 09-01-2004
Component:
Power train:axle assembly
Summary
Use of synthetic front axle lubricant for 4wd vehicles sold in cold weather climates. *tt this bulletin replaced previous bulletin dated 10/01/2003. *tt
Bulletin Number: 030861002B Bulletin Date: 09-01-2004
Component:
Structure:body
Summary
Snap/popping type noise coming from front of vehicle. *tt 03-08-61-002b, dated 05/01/2004 replaced. *tt
Bulletin Number: 30138019 Bulletin Date: 09-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Underhood air conditioner rattle noise heard on acceleration or a sudden loss of air conditioner system performance. *tt this bulletin replaces 03-01-38-019 dated 11-01-2003. to include various modles including 2002-2004 commercial up
Bulletin Number: 609 Bulletin Date: 09-01-2004
Component:
Suspension:front:hub
Summary
Front hub bearing grease leak. *sc
Bulletin Number: 30138019 Bulletin Date: 09-01-2004
Component:
353600 equipment:air conditioner
Summary
Underhood air conditioner rattle noise heard on acceleration or a sudden loss of air conditioner system performance. *tt this bulletin replaces 03-01-38-019 dated 11-01-2003. to include various modles including 2002-2004 commercial up
Bulletin Number: 30138019 Bulletin Date: 09-01-2004
Component:
353600 equipment:air conditioner
Summary
Underhood air conditioner rattle noise heard on acceleration or a sudden loss of air conditioner system performance. *tt this bulletin replaces 03-01-38-019 dated 11-01-2003. to include various modles including 2002-2004 commercial up
Bulletin Number: 609 Bulletin Date: 09-01-2004
Component:
021700 suspension:front:hub
Summary
Front hub bearing grease leak. *sc
Bulletin Number: 8242004 Bulletin Date: 08-24-2004
Component:
Power train
Summary
Bearing growl or rattle type noise while depressing or releasing the clutch pedal. *tt
Bulletin Number: 8242004 Bulletin Date: 08-24-2004
Component:
100000 power train
Summary
Bearing growl or rattle type noise while depressing or releasing the clutch pedal. *tt
Bulletin Number: 30730044 Bulletin Date: 08-01-2004
Component:
Power train:automatic transmission
Summary
Information on allison transmission service repairs - full service of internal components. *tt
Bulletin Number: 40138010 Bulletin Date: 08-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Diagnostic information to accurately diagnose a/c low pressure switch using new kent moore special tool ge-47742. *tt
Bulletin Number: 40139009 Bulletin Date: 08-01-2004
Component:
Visibility:defroster/defogger system:windshield:blower
Summary
Hvac blower motor inoperative or stays running. *tt
Bulletin Number: 40849019 Bulletin Date: 08-01-2004
Component:
Fuel system, other
Summary
Cranks but no start, stall, inaccurate/incorrect fuel gauge reading, no fuel, vehicle is out of fuel and fuel gauge reads above empty. *tt this bulletin replaces previous bulletin number 04-08-49-019. *tt
Bulletin Number: 20139007 Bulletin Date: 08-01-2004
Component:
Unknown or other
Summary
Automatic dual zone hvac battery draw. *ar
Bulletin Number: 40138010 Bulletin Date: 08-01-2004
Component:
353600 equipment:air conditioner
Summary
Diagnostic information to accurately diagnose a/c low pressure switch using new kent moore special tool ge-47742. *tt
Bulletin Number: 40139009 Bulletin Date: 08-01-2004
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary
Hvac blower motor inoperative or stays running. *tt
Bulletin Number: 40849019 Bulletin Date: 08-01-2004
Component:
090000 fuel system, other
Summary
Cranks but no start, stall, inaccurate/incorrect fuel gauge reading, no fuel, vehicle is out of fuel and fuel gauge reads above empty. *tt this bulletin replaces previous bulletin number 04-08-49-019. *tt
Bulletin Number: 20139007 Bulletin Date: 08-01-2004
Component:
980000 unknown or other
Summary
Automatic dual zone hvac battery draw. *ar
Bulletin Number: 20138007 Bulletin Date: 07-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Poor air conditioner performance - air conditioner will not blow cold enough. this service bulletin replaces 020138007a. *eh
Bulletin Number: 030864037A Bulletin Date: 07-01-2004
Component:
Visibility:power window devices and controls
Summary
Front power window noisy or inoperative. this service bulletin replaces 030864037a. see tsb id # 10005594 for original. *eh
Bulletin Number: 7012004 Bulletin Date: 07-01-2004
Component:
Equipment:other:owners/service/other manual
Summary
Oil life system reset procedures-trucks. buick terazza 2005, gmc sierra denali 2002-2003, gmc b7 chassis medium duty 2003-2005 and gmc 560 c-series 2003-2005 *sc
Bulletin Number: 20138007 Bulletin Date: 07-01-2004
Component:
353600 equipment:air conditioner
Summary
Poor air conditioner performance - air conditioner will not blow cold enough. this service bulletin replaces 020138007a. *eh
Bulletin Number: 030864037A Bulletin Date: 07-01-2004
Component:
133000 visibility:power window devices and controls
Summary
Front power window noisy or inoperative. this service bulletin replaces 030864037a. see tsb id # 10005594 for original. *eh
Bulletin Number: 7012004 Bulletin Date: 07-01-2004
Component:
355200 equipment:other:owners/service/other manual
Summary
Oil life system reset procedures-trucks. buick terazza 2005, gmc sierra denali 2002-2003, gmc b7 chassis medium duty 2003-2005 and gmc 560 c-series 2003-2005 *sc
Bulletin Number: 40523005 Bulletin Date: 06-01-2004
Component:
Service brakes, hydraulic
Summary
Availability of rear wheel mud flaps to reduce debris build-up on rear brake calipers and/or rear wheels. *tt
Bulletin Number: 40601018 Bulletin Date: 06-01-2004
Component:
Engine and engine cooling:engine
Summary
Information on revised design of intake gasket and related bolts for 2004 mid-year enhancement and prior year service usage. *tt
Bulletin Number: 40601020 Bulletin Date: 06-01-2004
Component:
Engine and engine cooling:engine
Summary
Engine oil leak near oil filter. *tt
Bulletin Number: 20730011 Bulletin Date: 06-01-2004
Component:
Power train:automatic transmission
Summary
Slow or no engagement of automatic transmission no start blank prndl display flashing prndl diagnostic trouble code p0708 p0872 p0847 p0875 p1711 p1713 or u1000 set. this service bulletin replaces 020730011. *eh
Bulletin Number: 30310002 Bulletin Date: 06-01-2004
Component:
Tires
Summary
Use of correct installation procedure for loose hubcap assembly. this service bulletin replaces 030310002. *eh
Bulletin Number: 40604043 Bulletin Date: 06-01-2004
Component:
Engine and engine cooling:engine
Summary
Unable to reset engine oil life monitor. *tt
Bulletin Number: 40138008 Bulletin Date: 06-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Heat ventilation and air conditioning system cannot be controlled or defaults to defrost mode. *eh
Bulletin Number: 40848003 Bulletin Date: 06-01-2004
Component:
Visibility:windshield
Summary
Windrush around windshield. *tt
Bulletin Number: 40852005 Bulletin Date: 06-01-2004
Component:
Equipment
Summary
Remote keyless entry (rke) system inoperative. *tt
Bulletin Number: 40941003 Bulletin Date: 06-01-2004
Component:
Air bags
Summary
Proper use of labor operation code when diagnosis leads to sir passenger presence system replacement. *tt
Bulletin Number: 40523005 Bulletin Date: 06-01-2004
Component:
030000 service brakes, hydraulic
Summary
Availability of rear wheel mud flaps to reduce debris build-up on rear brake calipers and/or rear wheels. *tt
Bulletin Number: 40601018 Bulletin Date: 06-01-2004
Component:
061000 engine and engine cooling:engine
Summary
Information on revised design of intake gasket and related bolts for 2004 mid-year enhancement and prior year service usage. *tt
Bulletin Number: 40601020 Bulletin Date: 06-01-2004
Component:
061000 engine and engine cooling:engine
Summary
Engine oil leak near oil filter. *tt
Bulletin Number: 20730011 Bulletin Date: 06-01-2004
Component:
103000 power train:automatic transmission
Summary
Slow or no engagement of automatic transmission no start blank prndl display flashing prndl diagnostic trouble code p0708 p0872 p0847 p0875 p1711 p1713 or u1000 set. this service bulletin replaces 020730011. *eh
Bulletin Number: 30310002 Bulletin Date: 06-01-2004
Component:
190000 tires
Summary
Use of correct installation procedure for loose hubcap assembly. this service bulletin replaces 030310002. *eh
Bulletin Number: 40604043 Bulletin Date: 06-01-2004
Component:
061000 engine and engine cooling:engine
Summary
Unable to reset engine oil life monitor. *tt
Bulletin Number: 40138008 Bulletin Date: 06-01-2004
Component:
353600 equipment:air conditioner
Summary
Heat ventilation and air conditioning system cannot be controlled or defaults to defrost mode. *eh
Bulletin Number: 40848003 Bulletin Date: 06-01-2004
Component:
131000 visibility:windshield
Summary
Windrush around windshield. *tt
Bulletin Number: 40852005 Bulletin Date: 06-01-2004
Component:
350000 equipment
Summary
Remote keyless entry (rke) system inoperative. *tt
Bulletin Number: 40941003 Bulletin Date: 06-01-2004
Component:
140000 air bags
Summary
Proper use of labor operation code when diagnosis leads to sir passenger presence system replacement. *tt
Bulletin Number: 990308002A Bulletin Date: 05-01-2004
Component:
Suspension:front
Summary
Front suspension coil spring noise. *tt
Bulletin Number: 30864010 Bulletin Date: 05-01-2004
Component:
Visibility:rearview mirrors/devices:exterior
Summary
Outside rearview mirrors may blow in at highway speeds or power folding feature appears inoperative. also to include 2005 models. *tt
Bulletin Number: 40601012 Bulletin Date: 05-01-2004
Component:
Engine and engine cooling
Summary
Rattle or crackling noise from engine compartment. *eh updated 03-07-06. *kb
Bulletin Number: 40604032 Bulletin Date: 05-01-2004
Component:
Engine and engine cooling
Summary
Proper method to secure fuel cap during refueling. *eh
Bulletin Number: 30864010 Bulletin Date: 05-01-2004
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary
Outside rearview mirrors may blow in at highway speeds or power folding feature appears inoperative. also to include 2005 models. *tt
Bulletin Number: 40601012 Bulletin Date: 05-01-2004
Component:
060000 engine and engine cooling
Summary
Rattle or crackling noise from engine compartment. *eh updated 03-07-06. *kb
Bulletin Number: 40604032 Bulletin Date: 05-01-2004
Component:
060000 engine and engine cooling
Summary
Proper method to secure fuel cap during refueling. *eh
Bulletin Number: 4222004 Bulletin Date: 04-22-2004
Component:
Power train:automatic transmission
Summary
Rattle type noise due to a cracked flex plate. gm voicemail express. *tt
Bulletin Number: 4222004 Bulletin Date: 04-22-2004
Component:
103000 power train:automatic transmission
Summary
Rattle type noise due to a cracked flex plate. gm voicemail express. *tt
Bulletin Number: 30604048 Bulletin Date: 04-01-2004
Component:
Fuel system, other
Summary
Revised fuel system diagnosis cab chassis. *tt
Bulletin Number: 000235003C Bulletin Date: 04-01-2004
Component:
Steering
Summary
Clunking noise under hood and can be felt in the steering wheel. *tt
Bulletin Number: 040604007A Bulletin Date: 04-01-2004
Component:
Engine and engine cooling
Summary
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. this service bulletin replaces 040604007. *eh
Bulletin Number: 040604007A Bulletin Date: 04-01-2004
Component:
060000 engine and engine cooling
Summary
Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. this service bulletin replaces 040604007. *eh
Bulletin Number: 1158 Bulletin Date: 03-15-2004
Component:
Unknown or other
Summary
Stop delivery order inspection claim submission. also including 2004 isuzu w-series. *mr
Bulletin Number: 1146 Bulletin Date: 03-12-2004
Component:
Unknown or other
Summary
Stop delivery order on certain vehicles with 4l80e or 4l8e automatic transmission. this also includes 2004 gmc, chevrolet w-medium duty and isuzu w series. *tt
Bulletin Number: 1148 Bulletin Date: 03-12-2004
Component:
Unknown or other
Summary
Stop delivery order (chevrolet bac 113611-114593). *mr
Bulletin Number: 3122004 Bulletin Date: 03-12-2004
Component:
Unknown or other
Summary
Please stop the delivery due to the limitations of the gm administrative message system. *tt
Bulletin Number: 3122004 Bulletin Date: 03-12-2004
Component:
980000 unknown or other
Summary
Please stop the delivery due to the limitations of the gm administrative message system. *tt
Bulletin Number: 20941002 Bulletin Date: 03-01-2004
Component:
Air bags
Summary
Air bag lamp on, passenger air bag indicator always reads off, diagnostic trouble code (dtc) b0092 set. *tt
Bulletin Number: 020421006C Bulletin Date: 03-01-2004
Component:
Power train:transfer case (4-wheel drive)
Summary
Inoperative 4wd/awd lamps, inoperative 4wd/awd system. *tt
Bulletin Number: 4019 Bulletin Date: 03-01-2004
Component:
Power train
Summary
4l80e / 4l85e transmission may have a condition in which the transmission overdrive gear set may fail due to inadequate lubrication as a result of a transmission casting change. customer satisfaction program bulletin. also to include 2004
Bulletin Number: 40495001 Bulletin Date: 03-01-2004
Component:
Power train:driveline:driveshaft
Summary
Revised wheel drive shaft nut torque specification. *tt
Bulletin Number: 40850007 Bulletin Date: 03-01-2004
Component:
Seats:front assembly:seat heater/cooler
Summary
Service information for front heated seat inoperative/cold. *mj
Bulletin Number: 40849007 Bulletin Date: 03-01-2004
Component:
Electrical system
Summary
Personal trip business trip feature must be on for trip odometer to accumulate. *eh
Bulletin Number: 40850003 Bulletin Date: 03-01-2004
Component:
Seat belts
Summary
Enabling memory seat feature via dic if feature appears inoperative. *eh
Bulletin Number: 40495001 Bulletin Date: 03-01-2004
Component:
105300 power train:driveline:driveshaft
Summary
Revised wheel drive shaft nut torque specification. *tt
Bulletin Number: 40850007 Bulletin Date: 03-01-2004
Component:
221700 seats:front assembly:seat heater/cooler
Summary
Service information for front heated seat inoperative/cold. *mj
Bulletin Number: 40849007 Bulletin Date: 03-01-2004
Component:
110000 electrical system
Summary
Personal trip business trip feature must be on for trip odometer to accumulate. *eh
Bulletin Number: 40850003 Bulletin Date: 03-01-2004
Component:
150000 seat belts
Summary
Enabling memory seat feature via dic if feature appears inoperative. *eh
Bulletin Number: 2172004 Bulletin Date: 02-17-2004
Component:
Visibility:glass, side/rear
Summary
Latch on the rear quarter glass is loose or has become detached from the window glass. gm voicemail express. *tt
Bulletin Number: 2172004 Bulletin Date: 02-17-2004
Component:
132000 visibility:glass, side/rear
Summary
Latch on the rear quarter glass is loose or has become detached from the window glass. gm voicemail express. *tt
Bulletin Number: 020605003C Bulletin Date: 02-01-2004
Component:
Engine and engine cooling:exhaust system
Summary
Exhaust moan/vibration. *tt update. *tt
Bulletin Number: 40864003 Bulletin Date: 02-01-2004
Component:
Visibility:power window devices and controls
Summary
Power window motor now available separately from the power window regulatory assembly. *tt updated *eh
Bulletin Number: 40603001 Bulletin Date: 02-01-2004
Component:
Engine and engine cooling
Summary
Incorrect amp code generator. *eh
Bulletin Number: 40603002 Bulletin Date: 02-01-2004
Component:
Engine and engine cooling
Summary
Diagnostic information for intermittent vehicle no crank dead battery. *eh
Bulletin Number: 40864003 Bulletin Date: 02-01-2004
Component:
133000 visibility:power window devices and controls
Summary
Power window motor now available separately from the power window regulatory assembly. *tt updated *eh
Bulletin Number: 40603001 Bulletin Date: 02-01-2004
Component:
060000 engine and engine cooling
Summary
Incorrect amp code generator. *eh
Bulletin Number: 40603002 Bulletin Date: 02-01-2004
Component:
060000 engine and engine cooling
Summary
Diagnostic information for intermittent vehicle no crank dead battery. *eh
Bulletin Number: 1292004 Bulletin Date: 01-29-2004
Component:
Visibility:power window devices and controls
Summary
Bulletin 04-08-64-003, front door power window motor assemblies - warranty repair information. *tt
Bulletin Number: 1292004 Bulletin Date: 01-29-2004
Component:
133000 visibility:power window devices and controls
Summary
Bulletin 04-08-64-003, front door power window motor assemblies - warranty repair information. *tt
Bulletin Number: 1470 Bulletin Date: 01-01-2004
Component:
Vehicle speed control
Summary
Erratic idle, idle surge, rough run, or near stall. *tt
Bulletin Number: 1555 Bulletin Date: 01-01-2004
Component:
Suspension
Summary
D height specification missing from si. sit bulletin 1410632. *tt
Bulletin Number: 1561 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Sizzle noise after vehicle shut off. service vme. sit bulletin 1410828. *tt
Bulletin Number: 1564 Bulletin Date: 01-01-2004
Component:
Visibility:rearview mirrors/devices:interior
Summary
Inside rearview mirror compass inoperative. service vme. sit bulletin 1411219. *tt
Bulletin Number: 1567 Bulletin Date: 01-01-2004
Component:
Steering
Summary
Quadrasteer service update. sit bulletin 1411394. *tt
Bulletin Number: 01332A Bulletin Date: 01-01-2004
Component:
Fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary
Tighten fuel cap message on the dic. sit bulletin 1411567. *tt
Bulletin Number: 1568 Bulletin Date: 01-01-2004
Component:
Fuel system, diesel:storage:tank assembly
Summary
Hard to fill fuel tank at high volume diesel pumps. sit bulletin 1411583. *tt
Bulletin Number: 1588 Bulletin Date: 01-01-2004
Component:
Fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary
Change in gas cap tether attachment point. service vme. sit bulletin 1414321. *tt
Bulletin Number: 1592 Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
2003-2004 generation 5 onstar steering wheel control function explanation. sit bulletin 1416474. *tt
Bulletin Number: 00908D Bulletin Date: 01-01-2004
Component:
Power train:manual transmission
Summary
6.6l and manual transmission growl noise while engaging or disengaging clutch. *tt *mj
Bulletin Number: 01485A Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Timing chain tensioner breakpoints for service kit or production fix for vehicle exhibiting rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. sit bulletin 1408407. *tt
Bulletin Number: 1531 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:exhaust system
Summary
Exhaust moan vibration. sit bulletin 1408514. *tt
Bulletin Number: 00574A Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
Allison lct1000 no shift, speedometer erratic/inoperative, diagnostic trouble codes (dtcs) p0721, c0237 possible anti-lock brake system (abs) lamp on. si bulletin 1408789. *tt
Bulletin Number: 1512 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine:diesel
Summary
6.6 liter duramax diesel engine fuel knock noise. various models including the 2004 gmc c4500 and c5500. sit bulletin 1406247. *tt
Bulletin Number: 1516 Bulletin Date: 01-01-2004
Component:
Suspension:front:shock absorber
Summary
Squeak noise emanating from the front shock area. sit bulletin 1404925. *tt
Bulletin Number: 01159A Bulletin Date: 01-01-2004
Component:
Visibility:rearview mirrors/devices:exterior
Summary
Outside rearview mirrors memory operation. sit bulletin 1404207. *tt
Bulletin Number: 702 Bulletin Date: 01-01-2004
Component:
Power train:automatic transmission
Summary
Slip condition in 2nd, 3rd or 4th damaged 2-4 band 3-4 clutch on the 4l60e/4l65e automatic transmission. *tt *mj
Bulletin Number: 1499 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
2004 6.6l duramax lb7 engines with extended crank during hot engine restart. diagnostic trouble code (dtc) p0193 may or may not be set. sit bulletin 1402202. *tt
Bulletin Number: 1496 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine:gasoline:turbo-charger
Summary
6.6l lb7 duramax diesel turbocharger noises or fuel economy complaint. service vme. sit bulletin 1401355. *tt
Bulletin Number: 1483 Bulletin Date: 01-01-2004
Component:
Power train:automatic transmission:control module (tcm, pcm)
Summary
Vehicle has no pcm (power train control module) communication with tech 2. sit bulletin 1400427. *tt
Bulletin Number: 1485 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Timing chain tensioner breakpoints for service kit or production fix. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. 4.3l lu3 l35 engine. *tt
Bulletin Number: 1493 Bulletin Date: 01-01-2004
Component:
Power train:automatic transmission
Summary
Allison lct1000 prndl flash and/or will not move with p0721, p0731, p0732, p0733, p0734, p0743, p0746, p0747, p0776, p0777, p1720, p1721, p1723 and p1724. *tt
Bulletin Number: 1495 Bulletin Date: 01-01-2004
Component:
Fuel system, diesel
Summary
Duramax diesel fuel in oil diagnostics. service vme. lb7 6.6l engine. sit bulletin 1401353. various models including 2003 and 2004 gmc c4500 and 5500 trucks. *tt
Bulletin Number: 001496A Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine:other fuel types:turbo-charger
Summary
This message is in regard to duramax turbocharger noises or possibly a performance or fuel economy complaint. service vme. 6.6 lb7 diesel engine. p0102, p0103, p0236. *tt
Bulletin Number: 1791 Bulletin Date: 01-01-2004
Component:
Seats:mid/rear assembly
Summary
Rear seat does not fold down into the stowed position.*mr
Bulletin Number: 1716 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Allison lct1000 transmission prndl inoperative and no communication with the tech 2 scan tool. sit bulletin 1455451. *tt
Bulletin Number: 1717 Bulletin Date: 01-01-2004
Component:
Unknown or other
Summary
6.6l lb7 engine - fuel rail pressure regulator harness connector servicing. *tt
Bulletin Number: 1774 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
6.6l lb7 repeat engine oil leak (left side) #2 main bearing cross bolt. *mr
Bulletin Number: 01242A Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary
6.6l lb7 lly diesel engine drive belt chirping on shut down. sit bulletin 1460352. *tt
Bulletin Number: 1790 Bulletin Date: 01-01-2004
Component:
Latches/locks/linkages
Summary
Rear quarter glass hinge (latch) loose. *mr
Bulletin Number: 00778A Bulletin Date: 01-01-2004
Component:
Structure
Summary
Business trip and/or personal trip odometer inoperative. sit bulletin 1460572. *tt
Bulletin Number: 1759 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:radio/tape deck/cd etc.
Summary
Xm rapid activation utilization. *mr
Bulletin Number: 1747 Bulletin Date: 01-01-2004
Component:
Fuel system, gasoline
Summary
Locking gas cap availability. *mr
Bulletin Number: 1736 Bulletin Date: 01-01-2004
Component:
Steering
Summary
Service 4 wheel steer message with diagnostic trouble code (dtc) c0455. sit bulletin 1459978. *tt
Bulletin Number: 1737 Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
Poor ground connection causing diagnostic trouble code (dtc) c0265. sit bulletin 1460187. *tt
Bulletin Number: 1761 Bulletin Date: 01-01-2004
Component:
Fuel system, other:storage:fuel gauge system
Summary
Fuel gauge diverts to empty after idling on incline. sit bulletin 1459166. *tt
Bulletin Number: 1698 Bulletin Date: 01-01-2004
Component:
Visibility:windshield
Summary
Windshield reveal molding flutering. service vme. sit bulletin 1450940. *tt
Bulletin Number: 1701 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
4.8 5.3 lm4 lm7 lr4 engine - with o2 sensor codes p0135, p0141, p0155, p0161. sit bulletin 1452753. *tt
Bulletin Number: 1704 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Programming control heads - hvac ac. *tt
Bulletin Number: 1712 Bulletin Date: 01-01-2004
Component:
Suspension:front
Summary
Left front of vehicle sits low. sit bulletin 1454860. *tt
Bulletin Number: 1714 Bulletin Date: 01-01-2004
Component:
Power train
Summary
The 4l60e/4l65e automatic transmission may experience a leak, inoperative/slipping in 2nd, 3rd and 4th gears or no movement (no forward or reverse) due to excess fluid loss. sit bulletin 1455088. *tt
Bulletin Number: 1897 Bulletin Date: 01-01-2004
Component:
Steering
Summary
Lack of steering assist or shudder during parking lot type maneuvers. *mr
Bulletin Number: 1935 Bulletin Date: 01-01-2004
Component:
Equipment:electrical
Summary
Product information on rear slider. *mr
Bulletin Number: 1901 Bulletin Date: 01-01-2004
Component:
Wheels
Summary
Excessive tire spin setting diagnostic trouble code (dtc) co542. also including 2002, 2003 sierra denali. *mr
Bulletin Number: 1946 Bulletin Date: 01-01-2004
Component:
Exterior lighting:hazard flashing warning lights
Summary
Hazard light flashes when turn signal applied. *mr
Bulletin Number: 1924 Bulletin Date: 01-01-2004
Component:
Suspension:front:control arm:lower arm
Summary
Front lower control arm change. *mr
Bulletin Number: 1939 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
4.3 4.8 5.3 6.0 lr4 lu3 lm7 l59 lq4 lq9 engines- evap code p0442. *mr
Bulletin Number: 1850 Bulletin Date: 01-01-2004
Component:
Seats:front assembly:seat heater/cooler
Summary
Drivers or passengers heated seats turn on by themselves. *mr
Bulletin Number: 1862 Bulletin Date: 01-01-2004
Component:
Seats
Summary
Driver personalization regarding memory seats. *mr
Bulletin Number: 1864 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:radio/tape deck/cd etc.
Summary
Radio cd skips/ejects or clock resets to 12:00. *mr *tt
Bulletin Number: 1863 Bulletin Date: 01-01-2004
Component:
Steering:electric power assist system
Summary
Lack of steering assist when stopped or during parking lot type maneuvers. *mr
Bulletin Number: 1824 Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
6.6l lly engine - diagnostic trouble code (dtc) u0106 resets or will not clear. *mr
Bulletin Number: 1856 Bulletin Date: 01-01-2004
Component:
Power train:automatic transmission:lever and linkage:column shift
Summary
Allison lct1000 will not shift from park due to ice, snow or mud build-up on shift linkage. *mr
Bulletin Number: 1822 Bulletin Date: 01-01-2004
Component:
Structure
Summary
Front door frame contacts the windshield reveal molding. *mr
Bulletin Number: 1919 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:radio/tape deck/cd etc.
Summary
Replacement radio reads cal error, has no audio or will not program. *tt
Bulletin Number: 1966 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Inoperative air conditioner system or lack of cooling. *mr
Bulletin Number: 1953 Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
Abs and red brake malfunction indicator light on with no diagnostic trouble codes. *mr
Bulletin Number: 2029 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Inaccurate fuel gauge readings and/or engine stall. *mr
Bulletin Number: 2029 Bulletin Date: 01-01-2004
Component:
Fuel system, gasoline
Summary
Inaccurate fuel gauge readings and/or engine stall. *mr
Bulletin Number: 1958 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:radio/tape deck/cd etc.
Summary
Product information regarding radio personalization. *mr
Bulletin Number: 1999 Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
Diagnostic trouble code tips- lct1000 transmission. *mr
Bulletin Number: 1989 Bulletin Date: 01-01-2004
Component:
Fuel system, diesel
Summary
6.6l lly diesel engine fuelinjector compression leak noise or soot around the injector body.*mr
Bulletin Number: 2007 Bulletin Date: 01-01-2004
Component:
Visibility:rearview mirrors/devices:exterior
Summary
Power folding mirrors will not fold inward.*mr
Bulletin Number: 1955 Bulletin Date: 01-01-2004
Component:
Latches/locks/linkages
Summary
Passenger door module lock up.*mr
Bulletin Number: 2013 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:cooling system
Summary
Coolant leak from head cup plugs on gen iii engines. *mr
Bulletin Number: 1640 Bulletin Date: 01-01-2004
Component:
Service brakes, hydraulic:antilock:control unit/module
Summary
Electronic brake control module part restriction.*mr *mj
Bulletin Number: 1601 Bulletin Date: 01-01-2004
Component:
Visibility:windshield wiper/washer:linkages
Summary
Windshield wiper arm loose.*mr
Bulletin Number: 1619 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
6.6 lly engine glow plugs are not interchangeable with the current 6.6 lb7 glow plugs.*mr
Bulletin Number: 01761B Bulletin Date: 01-01-2004
Component:
Fuel system, gasoline:delivery
Summary
Fuel gauge diverts to empty after idling on incline or refueling. *nm
Bulletin Number: 1622 Bulletin Date: 01-01-2004
Component:
Equipment
Summary
Secondary sunshade visor elimination.*mr
Bulletin Number: 1634 Bulletin Date: 01-01-2004
Component:
Steering
Summary
Intermediate steering shaft service kit. service vme. *tt
Bulletin Number: 1654 Bulletin Date: 01-01-2004
Component:
Power train:automatic transmission
Summary
Squawk or grunt noise that occurs on the 2-3 upshift on vehicles with 4l60e - m30, 4l60e m32 transmission. *tt
Bulletin Number: 1624 Bulletin Date: 01-01-2004
Component:
Fuel system, gasoline:fuel injection system
Summary
Gen iii engines with maf (mass airflow) sensor code p0101. *tt
Bulletin Number: 1678 Bulletin Date: 01-01-2004
Component:
Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary
6.6 lly duramax diesel engines have an issue with the high pressure fuel lines that prevent them from achieving the proper torque upon reinstallation after a repair. *tt
Bulletin Number: 1662 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:radio/tape deck/cd etc.
Summary
Xm error on a radio display. *tt
Bulletin Number: 00764B Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
6.6l diesel engine rough idle, clatter, stall and/or diagnostic trouble code (dtc) p1223. *tt
Bulletin Number: 01485B Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Timing chain tensioner breakpoints for service kit or production fix. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. 4.3l lu3 l35 engine. *tt
Bulletin Number: 01919A Bulletin Date: 01-01-2004
Component:
Equipment:electrical:radio/tape deck/cd etc.
Summary
Replacement radio reads cal error, has no audio or will not program. *tt
Bulletin Number: 01222A Bulletin Date: 01-01-2004
Component:
Power train:axle hubs
Summary
Repeat rear axle hub seal leak. *tt
Bulletin Number: 01588A Bulletin Date: 01-01-2004
Component:
Fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary
Fuel cap tether strap too short. *tt
Bulletin Number: 00678B Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Engine overheats on vehicles equipped with rpo vyu snowplow prep package. *tt
Bulletin Number: 00372D Bulletin Date: 01-01-2004
Component:
Equipment:electrical
Summary
Onstar system is attempting and/or completing phone calls which the operator of the vehicle did not initiate. *tt
Bulletin Number: 00442A Bulletin Date: 01-01-2004
Component:
Air bags
Summary
Dual stage air bag used in single stage application. *tt
Bulletin Number: 01737A Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
Poor ground connection causing diagnostic trouble code (dtc) c0265. *tt
Bulletin Number: 2116 Bulletin Date: 01-01-2004
Component:
Power train:driveline
Summary
Highway speed vibration on k2500hd 4wd vehicles equipped with a 4l80e automatic transmission. *tt
Bulletin Number: 2113 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Intermittent no forward or reverse with possibly either a flashing prndl display or a range shift inhibited message. *tt
Bulletin Number: 844 Bulletin Date: 01-01-2004
Component:
Visibility:windshield wiper/washer
Summary
Front windshield wiper arm does not remain upright position as it did on prior models and as a result, customer may inadvertently brake the wiper arm trying to extend the blade. *mj
Bulletin Number: 00609B Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Low power, will not go over 2300 rpms. 6.6l lb7 engine. *tt
Bulletin Number: 00968A Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine:diesel
Summary
6.6l lb7 lly diesel engine with rough, unstable, low idle speed or stall. *tt
Bulletin Number: 1845 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Normal engine operating noise characteristics. *tt
Bulletin Number: 01119A Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Roll-out for the gen iii small block engines with iridium spark plugs. also includes 2003/2004 m/l vans. *tt
Bulletin Number: 1977 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Allison lct1000 prndl flash and/or will not move. *tt
Bulletin Number: 1972 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Erratic oil pressure gmt 610 or gmt800 with codes p0522 or p0523. *tt 01972a replaced and updated 01/01/04. *sc
Bulletin Number: 00700A Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
4.3l l35 engine wide open throttle diagnostic trouble code (dtc) p0335, p0336, p0339. *tt *mj
Bulletin Number: 266 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Loss of power, hesitates on acceleration on 4.8, 5.3 and 6.0 engines coupled with the 4l60e or 4l65e transmission. *tt
Bulletin Number: 1330 Bulletin Date: 01-01-2004
Component:
Power train:automatic transmission
Summary
Allison lct1000 buzz, moan noise at 1400 rpm with the 8.1 l18 gas engine. *tt
Bulletin Number: 573 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:radio/tape deck/cd etc.
Summary
Low audio output from speakers. *mj
Bulletin Number: 01267F Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
Service 4wd light on no codes besides u1000 codes or c0550. *mj
Bulletin Number: 01217B Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
Allison lct1000 diagnostic trouble codes (dtc) p1711, p0872 after completing repairs. *mj
Bulletin Number: 1586 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
8.1l changes in heads, bolts and gasket for for 2004 1/2 engines. various models including the chevrolet and gmc 2500hd/3500 my2001-2004 and 2001, 2002, and 2003 gmt 560. *mj
Bulletin Number: 677 Bulletin Date: 01-01-2004
Component:
Unknown or other
Summary
Snow plow prep package information - service vme. *mj
Bulletin Number: 786 Bulletin Date: 01-01-2004
Component:
Vehicle speed control:accelerator pedal
Summary
Buzz noise and virbation in the accelerator pedal at approx. 10 mph on start up. *mj
Bulletin Number: 2051 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Intermittent service engine soon (ses) light comes on and code p0700 along with diagnostic trouble code p0742 stored. *tt
Bulletin Number: 2052 Bulletin Date: 01-01-2004
Component:
Structure
Summary
Noise coming from instrument panel cluster or tachometer. *tt
Bulletin Number: 2055 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
Engine oil in the turbo charge air cooler pipes and hoses. *tt
Bulletin Number: 2092 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
Gurgle noise may be heard from the engine coolant compartment on trucks built with rpo hp2 parallel hybrid system. *tt
Bulletin Number: 2069 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Allison lct1000 range inhibit and/or will not move. *tt
Bulletin Number: 2089 Bulletin Date: 01-01-2004
Component:
Fuel system, other:storage:fuel gauge system
Summary
Inaccurate fuel gauge readings and/or engine stall. service vme. *tt
Bulletin Number: 856 Bulletin Date: 01-01-2004
Component:
Power train:automatic transmission
Summary
Allison lct1000 oil pump whine, buzz on cold start. *tt
Bulletin Number: 993 Bulletin Date: 01-01-2004
Component:
Visibility:rearview mirrors/devices:exterior
Summary
Outside rearview mirror glass may crack. *tt
Bulletin Number: 1927 Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
A no charge condition with diagnostic trouble code (dtc) p0380, p0621. *tt
Bulletin Number: 01188A Bulletin Date: 01-01-2004
Component:
Exterior lighting:hazard flashing warning lights:unit
Summary
Unable to locate emergency light relay and/or blunt cut wires. *tt
Bulletin Number: 01250C Bulletin Date: 01-01-2004
Component:
Electrical system:battery
Summary
Battery or charge indicator light remains on for up to 30 seconds after a cold start and engine running. *tt
Bulletin Number: 00872A Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Oil pan or oil cooler line leak on gen iii v-8 engines equipped with an oil cooler. *tt
Bulletin Number: 1353 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Engine misfire due to injector fretting corrosion. *tt
Bulletin Number: 00823A Bulletin Date: 01-01-2004
Component:
Steering:hydraulic power assist:power steering fluid
Summary
Power steering fluid leaking at hydraulic brake booster. *tt
Bulletin Number: 3011 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Repeat engine oil leak at main bearing side bolt. *tt
Bulletin Number: 3015 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
6.0l lq4 vin u engine restriction. *tt
Bulletin Number: 1531156 Bulletin Date: 01-01-2004
Component:
Fuel system, diesel
Summary
Parts showing no stock or not available. *mj
Bulletin Number: 1530076 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Vehicles and hummer h2 with a high altitude stall. *mj
Bulletin Number: 3014 Bulletin Date: 01-01-2004
Component:
Fuel system, gasoline:delivery:fuel pump
Summary
Fuel sender information on trucks with 6.6l diesel. *tt
Bulletin Number: 3015 Bulletin Date: 01-01-2004
Component:
Suspension
Summary
Wheel alignment specs for spring special and texas truck. *tt
Bulletin Number: 3028 Bulletin Date: 01-01-2004
Component:
Suspension:rear
Summary
Replacement tailgate cables bind at shoulder bolt. *mj
Bulletin Number: 3018 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Engine cylinder head cup plug coolant leak. *mj
Bulletin Number: 3010 Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
Glow plug control module loss of communication, possible diagnostic trouble code (dtc) u0106 set, and dtc will not clear. *tt
Bulletin Number: 3025 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
04 model year 4.8.5.3.7.6.0 gen iii engine piston pin information. *mj
Bulletin Number: 313 Bulletin Date: 01-01-2004
Component:
Suspension
Summary
Squeak or creak noise from underbody over bumps. *mj
Bulletin Number: 3004 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
4.8l 5.3l 6.6l 8.1l p1285 p1286 or p2133 after replacing app sensor. *mj
Bulletin Number: 3000 Bulletin Date: 01-01-2004
Component:
Structure:body:door
Summary
Service vme - 03 - 04 full size truck, utilities and hummer h2 passenger door module inoperative. *mj
Bulletin Number: 3011 Bulletin Date: 01-01-2004
Component:
Equipment
Summary
When using voice recognition dialing, some numbers or commands may not be understood by the system especially the number two (2). *tt
Bulletin Number: 3000A Bulletin Date: 01-01-2004
Component:
Suspension:rear
Summary
Rear axle locking differential chatter shudder noise on turns. *mj
Bulletin Number: 3067 Bulletin Date: 01-01-2004
Component:
Structure:body:roof and pillars
Summary
Tinny rattle type noise from the roof at highway speeds. *tt
Bulletin Number: 3045 Bulletin Date: 01-01-2004
Component:
Wheels
Summary
Various steering or suspension concerns after gm accessories 20 inch tire/wheel assemblies have been installed. *tt
Bulletin Number: 3051 Bulletin Date: 01-01-2004
Component:
Vehicle speed control:cruise control
Summary
Cruise control and/or the power take off unit (pto) may be inoperative. *tt
Bulletin Number: 3048 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary
Timing chain tensioner breakpoints for service kit or production kit. supplement to 03-06-01-024b. *tt
Bulletin Number: 3086 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Air conditioner (a/c) low pressure switch diagnostic tool. currently the a/c low pressure switch open/close pressures cannot be accurately determined by measuring pressure at the low side service port. *tt
Bulletin Number: 3084 Bulletin Date: 01-01-2004
Component:
Electrical system:starter assembly
Summary
Starter grinding noise during cranking on vehicles equipped with the allison automatic transmission. *tt
Bulletin Number: 3086 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Whistle noise from the throttle body area on light throttle acceleration on vehicles with gen iii engines and electronic throttle. *tt
Bulletin Number: 3087 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Crank no start with no cranking rpm spark or injector pulse. *tt
Bulletin Number: 3087 Bulletin Date: 01-01-2004
Component:
Fuel system, other
Summary
Updated part number for bulletin 04-08-49-019 stall, inaccurate/incorrect fuel gauge reading. *tt
Bulletin Number: 3089 Bulletin Date: 01-01-2004
Component:
Structure:body
Summary
Rattle type noise coming from the rear of the cab during body twist maneuvers or over bumps. *tt
Bulletin Number: 3073 Bulletin Date: 01-01-2004
Component:
Vehicle speed control:cruise control
Summary
Downhill cruise control surge. *tt
Bulletin Number: 3076 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Repeat hvac blower motor failure. *tt
Bulletin Number: 3022A Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
04 full size trucks and utilities with vin g, n, t, v and u engines may have a high altitude, high ambient temperature stall. *tt
Bulletin Number: 3072 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:cooling system
Summary
The engine coolant temperature or intake air temperature sensor may read -40 degrees when monitored with tech 2. *tt
Bulletin Number: 3050A Bulletin Date: 01-01-2004
Component:
Equipment
Summary
02-05 onstar equipped vehicles emitting beeping noise before connecting to onstar. *tt
Bulletin Number: 3039 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:radio/tape deck/cd etc.
Summary
Auto volume inoperative after ignition key is cycled. various models including 03-04 cadillac all full size utilities. *tt
Bulletin Number: 3038 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Engine tick, rattle or knock noise after cylinder head gasket replacement on the 6.0l engine. *tt
Bulletin Number: 3057 Bulletin Date: 01-01-2004
Component:
Steering
Summary
Intermittent concern of the service 4 wheel steer message being displayed on the dic. *tt
Bulletin Number: 3054 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Replacement flexplate may have larger bolt holes than the original flexplate. *tt
Bulletin Number: 3055 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:engine
Summary
Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt
Bulletin Number: 3062 Bulletin Date: 01-01-2004
Component:
Unknown or other
Summary
Additional part numbers for bulletin 02-01-38-007b. *tt
Bulletin Number: 3063 Bulletin Date: 01-01-2004
Component:
Other:school bus stop arm assembly
Summary
Performance package rpo pcx. *tt
Bulletin Number: 30559 Bulletin Date: 01-01-2004
Component:
Power train:automatic transmission
Summary
Allison lct1000 diagnostic trouble code p1711, p0872 after completing repairs. *tt
Bulletin Number: 3128 Bulletin Date: 01-01-2004
Component:
Structure
Summary
All full size trucks pick up box sheet metal fracture/damage with aftermarket accessories installed. *sc
Bulletin Number: 3109 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
Engineering is investigating the 04 6.6l lb7 injectors for concerns of dtc p1093 and high return line flow rates. *sc
Bulletin Number: 3147 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
Concerns regarding bulletin 00-02-35-003f. all full size trucks and utilities and hummer parts available. *tc
Bulletin Number: 3155 Bulletin Date: 01-01-2004
Component:
Vehicle speed control
Summary
Speedometer inoperative. *tc
Bulletin Number: 3129A Bulletin Date: 01-01-2004
Component:
Fuel system, gasoline
Summary
Smoke, fuel knock, surging, and high injector balance rates. *tc to include 2005 chevrolet kodiak and gmc topkick. *tt
Bulletin Number: 3100 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
Low power service engine soon/malfunction indicator light on diagnostic trouble code p0116 and p0299. *sc
Bulletin Number: 3157 Bulletin Date: 01-01-2004
Component:
Tires
Summary
Excessive tire spin setting diagnostic trouble code c0543. *tc
Bulletin Number: 3110 Bulletin Date: 01-01-2004
Component:
Fuel system, other:storage:tank assembly:pressure relief devices
Summary
Erratic oil pressure with diagnostic trouble code's p0522 and/or p0523. *sc
Bulletin Number: 3159 Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
Instrument panel cluster parts restriction. *tc
Bulletin Number: 3160 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
Gas engines exhaust buzz or rattle noise. *tc
Bulletin Number: 3121 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc
Bulletin Number: 3101 Bulletin Date: 01-01-2004
Component:
Vehicle speed control
Summary
Engine low speed engine rpm surge. *sc
Bulletin Number: 3130 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Allison lct 1000 prndl flash and/or will not move. *tc
Bulletin Number: 3119 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary
Engineering investigation - catalytic converter replacement. *sc
Bulletin Number: 3138 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
Accessory drive belt chirp noise at cold idle. *tc
Bulletin Number: 3120 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:navigational system(global positioning system)
Summary
Onstar center unable to perform remote diagnostic. (2004-2005 chevrolet yukon, 2005 chevrolet trailblazer, 2002, 2003, 2005 buick rainier, 2005 chevrolet express van, and 2005 cadillac seville) *sc
Bulletin Number: 3106 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:radio/tape deck/cd etc.
Summary
Xm radio was working prior to july 26, 2004 and it is inoperative now. *jb
Bulletin Number: 3121 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
6.6 lb7 engine with a no charge condition with diagnostic trouble code p0380 p0621. *sc
Bulletin Number: 3107 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc
Bulletin Number: 3113 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:navigational system(global positioning system)
Summary
Gen 6 vehicles in mount airy, nc cannot connect to onstar or emergency services. *sc
Bulletin Number: 3095 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Allison lct 1000 transmission prndl inoperative and no communication with the tech 2 scan tool. *sc updated *eh
Bulletin Number: 3092 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Allison lct 1000 buzz noise feel on tcc apply. *sc
Bulletin Number: 3090 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:navigational system(global positioning system)
Summary
Unable to perform set up new onstar on vehicles with gen 6.05 hardware. *sc
Bulletin Number: 3097 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling
Summary
Oil pan or oil cooler line leak. *sc
Bulletin Number: 3094 Bulletin Date: 01-01-2004
Component:
Electrical system
Summary
Allison lct 1000 p1781 or p0802 setting in the electronic control module. (2005 chevrolet kodiak and 2005 gmc top kick) *sc
Bulletin Number: 3121 Bulletin Date: 01-01-2004
Component:
Engine and engine cooling:cooling system
Summary
Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc
Bulletin Number: 837 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Allison lct1000 overdrive disable lamp inoperative after installation of instrument panel (ip). *tt
Bulletin Number: 3179 Bulletin Date: 01-01-2004
Component:
Equipment:electrical:air conditioner
Summary
Automatic dual zone hvac battery draw supplement to 02-01-39-007a. *tt
Bulletin Number: 3151 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Allison lct1000 transmission hard to remove from park. *tt
Bulletin Number: 40731001 Bulletin Date: 01-01-2004
Component:
Power train
Summary
Revised clutch pressure plate adjustment. *tt
Bulletin Number: 3000A Bulletin Date: 01-01-2004
Component:
022000 suspension:rear
Summary
Rear axle locking differential chatter shudder noise on turns. *mj
Bulletin Number: 1470 Bulletin Date: 01-01-2004
Component:
180000 vehicle speed control
Summary
Erratic idle, idle surge, rough run, or near stall. *tt
Bulletin Number: 00823A Bulletin Date: 01-01-2004
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary
Power steering fluid leaking at hydraulic brake booster. *tt
Bulletin Number: 1470 Bulletin Date: 01-01-2004
Component:
180000 vehicle speed control
Summary
Erratic idle, idle surge, rough run, or near stall. *tt
Bulletin Number: 00823A Bulletin Date: 01-01-2004
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary
Power steering fluid leaking at hydraulic brake booster. *tt
Bulletin Number: 3011 Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
Repeat engine oil leak at main bearing side bolt. *tt
Bulletin Number: 3015 Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
6.0l lq4 vin u engine restriction. *tt
Bulletin Number: 1531156 Bulletin Date: 01-01-2004
Component:
080000 fuel system, diesel
Summary
Parts showing no stock or not available. *mj
Bulletin Number: 1530076 Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
Vehicles and hummer h2 with a high altitude stall. *mj
Bulletin Number: 3014 Bulletin Date: 01-01-2004
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary
Fuel sender information on trucks with 6.6l diesel. *tt
Bulletin Number: 3015 Bulletin Date: 01-01-2004
Component:
020000 suspension
Summary
Wheel alignment specs for spring special and texas truck. *tt
Bulletin Number: 3028 Bulletin Date: 01-01-2004
Component:
022000 suspension:rear
Summary
Replacement tailgate cables bind at shoulder bolt. *mj
Bulletin Number: 3018 Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
Engine cylinder head cup plug coolant leak. *mj
Bulletin Number: 3010 Bulletin Date: 01-01-2004
Component:
110000 electrical system
Summary
Glow plug control module loss of communication, possible diagnostic trouble code (dtc) u0106 set, and dtc will not clear. *tt
Bulletin Number: 3025 Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
04 model year 4.8.5.3.7.6.0 gen iii engine piston pin information. *mj
Bulletin Number: 313 Bulletin Date: 01-01-2004
Component:
020000 suspension
Summary
Squeak or creak noise from underbody over bumps. *mj
Bulletin Number: 3004 Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
4.8l 5.3l 6.6l 8.1l p1285 p1286 or p2133 after replacing app sensor. *mj
Bulletin Number: 3000 Bulletin Date: 01-01-2004
Component:
162300 structure:body:door
Summary
Service vme - 03 - 04 full size truck, utilities and hummer h2 passenger door module inoperative. *mj
Bulletin Number: 3011 Bulletin Date: 01-01-2004
Component:
350000 equipment
Summary
When using voice recognition dialing, some numbers or commands may not be understood by the system especially the number two (2). *tt
Bulletin Number: 3000A Bulletin Date: 01-01-2004
Component:
022000 suspension:rear
Summary
Rear axle locking differential chatter shudder noise on turns. *mj
Bulletin Number: 3067 Bulletin Date: 01-01-2004
Component:
162900 structure:body:roof and pillars
Summary
Tinny rattle type noise from the roof at highway speeds. *tt
Bulletin Number: 3045 Bulletin Date: 01-01-2004
Component:
200000 wheels
Summary
Various steering or suspension concerns after gm accessories 20 inch tire/wheel assemblies have been installed. *tt
Bulletin Number: 3051 Bulletin Date: 01-01-2004
Component:
185000 vehicle speed control:cruise control
Summary
Cruise control and/or the power take off unit (pto) may be inoperative. *tt
Bulletin Number: 3048 Bulletin Date: 01-01-2004
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary
Timing chain tensioner breakpoints for service kit or production kit. supplement to 03-06-01-024b. *tt
Bulletin Number: 3086 Bulletin Date: 01-01-2004
Component:
353600 equipment:air conditioner
Summary
Air conditioner (a/c) low pressure switch diagnostic tool. currently the a/c low pressure switch open/close pressures cannot be accurately determined by measuring pressure at the low side service port. *tt
Bulletin Number: 3084 Bulletin Date: 01-01-2004
Component:
113000 electrical system:starter assembly
Summary
Starter grinding noise during cranking on vehicles equipped with the allison automatic transmission. *tt
Bulletin Number: 3086 Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
Whistle noise from the throttle body area on light throttle acceleration on vehicles with gen iii engines and electronic throttle. *tt
Bulletin Number: 3087 Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
Crank no start with no cranking rpm spark or injector pulse. *tt
Bulletin Number: 3087 Bulletin Date: 01-01-2004
Component:
090000 fuel system, other
Summary
Updated part number for bulletin 04-08-49-019 stall, inaccurate/incorrect fuel gauge reading. *tt
Bulletin Number: 3089 Bulletin Date: 01-01-2004
Component:
162000 structure:body
Summary
Rattle type noise coming from the rear of the cab during body twist maneuvers or over bumps. *tt
Bulletin Number: 3073 Bulletin Date: 01-01-2004
Component:
185000 vehicle speed control:cruise control
Summary
Downhill cruise control surge. *tt
Bulletin Number: 3076 Bulletin Date: 01-01-2004
Component:
353600 equipment:air conditioner
Summary
Repeat hvac blower motor failure. *tt
Bulletin Number: 3022A Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
04 full size trucks and utilities with vin g, n, t, v and u engines may have a high altitude, high ambient temperature stall. *tt
Bulletin Number: 3072 Bulletin Date: 01-01-2004
Component:
062000 engine and engine cooling:cooling system
Summary
The engine coolant temperature or intake air temperature sensor may read -40 degrees when monitored with tech 2. *tt
Bulletin Number: 3050A Bulletin Date: 01-01-2004
Component:
350000 equipment
Summary
02-05 onstar equipped vehicles emitting beeping noise before connecting to onstar. *tt
Bulletin Number: 3039 Bulletin Date: 01-01-2004
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary
Auto volume inoperative after ignition key is cycled. various models including 03-04 cadillac all full size utilities. *tt
Bulletin Number: 3038 Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
Engine tick, rattle or knock noise after cylinder head gasket replacement on the 6.0l engine. *tt
Bulletin Number: 3057 Bulletin Date: 01-01-2004
Component:
010000 steering
Summary
Intermittent concern of the service 4 wheel steer message being displayed on the dic. *tt
Bulletin Number: 3054 Bulletin Date: 01-01-2004
Component:
100000 power train
Summary
Replacement flexplate may have larger bolt holes than the original flexplate. *tt
Bulletin Number: 3055 Bulletin Date: 01-01-2004
Component:
061000 engine and engine cooling:engine
Summary
Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt
Bulletin Number: 3062 Bulletin Date: 01-01-2004
Component:
980000 unknown or other
Summary
Additional part numbers for bulletin 02-01-38-007b. *tt
Bulletin Number: 3063 Bulletin Date: 01-01-2004
Component:
982000 other:school bus stop arm assembly
Summary
Performance package rpo pcx. *tt
Bulletin Number: 30559 Bulletin Date: 01-01-2004
Component:
103000 power train:automatic transmission
Summary
Allison lct1000 diagnostic trouble code p1711, p0872 after completing repairs. *tt
Bulletin Number: 3128 Bulletin Date: 01-01-2004
Component:
160000 structure
Summary
All full size trucks pick up box sheet metal fracture/damage with aftermarket accessories installed. *sc
Bulletin Number: 3109 Bulletin Date: 01-01-2004
Component:
060000 engine and engine cooling
Summary
Engineering is investigating the 04 6.6l lb7 injectors for concerns of dtc p1093 and high return line flow rates. *sc
Bulletin Number: 3147 Bulletin Date: 01-01-2004
Component:
060000 engine and engine cooling
Summary
Concerns regarding bulletin 00-02-35-003f. all full size trucks and utilities and hummer parts available. *tc
Bulletin Number: 3155 Bulletin Date: 01-01-2004
Component:
180000 vehicle speed control
Summary
Speedometer inoperative. *tc
Bulletin Number: 3129A Bulletin Date: 01-01-2004
Component:
070000 fuel system, gasoline
Summary
Smoke, fuel knock, surging, and high injector balance rates. *tc to include 2005 chevrolet kodiak and gmc topkick. *tt
Bulletin Number: 3100 Bulletin Date: 01-01-2004
Component:
060000 engine and engine cooling
Summary
Low power service engine soon/malfunction indicator light on diagnostic trouble code p0116 and p0299. *sc
Bulletin Number: 3157 Bulletin Date: 01-01-2004
Component:
190000 tires
Summary
Excessive tire spin setting diagnostic trouble code c0543. *tc
Bulletin Number: 3110 Bulletin Date: 01-01-2004
Component:
091130 fuel system, other:storage:tank assembly:pressure relief devices
Summary
Erratic oil pressure with diagnostic trouble code's p0522 and/or p0523. *sc
Bulletin Number: 3159 Bulletin Date: 01-01-2004
Component:
110000 electrical system
Summary
Instrument panel cluster parts restriction. *tc
Bulletin Number: 3160 Bulletin Date: 01-01-2004
Component:
060000 engine and engine cooling
Summary
Gas engines exhaust buzz or rattle noise. *tc
Bulletin Number: 3121 Bulletin Date: 01-01-2004
Component:
060000 engine and engine cooling
Summary
Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc
Bulletin Number: 3101 Bulletin Date: 01-01-2004
Component:
180000 vehicle speed control
Summary
Engine low speed engine rpm surge. *sc
Bulletin Number: 3130 Bulletin Date: 01-01-2004
Component:
100000 power train
Summary
Allison lct 1000 prndl flash and/or will not move. *tc
Bulletin Number: 3119 Bulletin Date: 01-01-2004
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary
Engineering investigation - catalytic converter replacement. *sc
Bulletin Number: 3138 Bulletin Date: 01-01-2004
Component:
060000 engine and engine cooling
Summary
Accessory drive belt chirp noise at cold idle. *tc
Bulletin Number: 3120 Bulletin Date: 01-01-2004
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary
Onstar center unable to perform remote diagnostic. (2004-2005 chevrolet yukon, 2005 chevrolet trailblazer, 2002, 2003, 2005 buick rainier, 2005 chevrolet express van, and 2005 cadillac seville) *sc
Bulletin Number: 3106 Bulletin Date: 01-01-2004
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary
Xm radio was working prior to july 26, 2004 and it is inoperative now. *jb
Bulletin Number: 3121 Bulletin Date: 01-01-2004
Component:
060000 engine and engine cooling
Summary
6.6 lb7 engine with a no charge condition with diagnostic trouble code p0380 p0621. *sc
Bulletin Number: 3107 Bulletin Date: 01-01-2004
Component:
060000 engine and engine cooling
Summary
P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc
Bulletin Number: 3113 Bulletin Date: 01-01-2004
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary
Gen 6 vehicles in mount airy, nc cannot connect to onstar or emergency services. *sc
Bulletin Number: 3095 Bulletin Date: 01-01-2004
Component:
100000 power train
Summary
Allison lct 1000 transmission prndl inoperative and no communication with the tech 2 scan tool. *sc updated *eh
Bulletin Number: 3092 Bulletin Date: 01-01-2004
Component:
100000 power train
Summary
Allison lct 1000 buzz noise feel on tcc apply. *sc
Bulletin Number: 3090 Bulletin Date: 01-01-2004
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary
Unable to perform set up new onstar on vehicles with gen 6.05 hardware. *sc
Bulletin Number: 3097 Bulletin Date: 01-01-2004
Component:
060000 engine and engine cooling
Summary
Oil pan or oil cooler line leak. *sc
Bulletin Number: 3094 Bulletin Date: 01-01-2004
Component:
110000 electrical system
Summary
Allison lct 1000 p1781 or p0802 setting in the electronic control module. (2005 chevrolet kodiak and 2005 gmc top kick) *sc
Bulletin Number: 3121 Bulletin Date: 01-01-2004
Component:
062000 engine and engine cooling:cooling system
Summary
Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc
Bulletin Number: 837 Bulletin Date: 01-01-2004
Component:
100000 power train
Summary
Allison lct1000 overdrive disable lamp inoperative after installation of instrument panel (ip). *tt
Bulletin Number: 3179 Bulletin Date: 01-01-2004
Component:
353600 equipment:air conditioner
Summary
Automatic dual zone hvac battery draw supplement to 02-01-39-007a. *tt
Bulletin Number: 3151 Bulletin Date: 01-01-2004
Component:
100000 power train
Summary
Allison lct1000 transmission hard to remove from park. *tt
Bulletin Number: 40731001 Bulletin Date: 01-01-2004
Component:
100000 power train
Summary
Revised clutch pressure plate adjustment. *tt
Bulletin Number: 01267A Bulletin Date: 11-18-2003
Component:
Power train:transfer case (4-wheel drive)
Summary
Service 4wd light on, the 4wd is inoperative and no codes besides u1000 codes. service vme. *tt
Bulletin Number: 1332 Bulletin Date: 11-18-2003
Component:
Fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary
Dic message that the fuel cap is not on tight. service vme. *tt
Bulletin Number: 1329 Bulletin Date: 11-18-2003
Component:
Unknown or other
Summary
2004 new model product changes. service vme. *tt
Bulletin Number: 1339 Bulletin Date: 11-18-2003
Component:
Engine and engine cooling:cooling system:fan
Summary
Hvac blower motor fan stays on in the high blower position. service vme. *tt
Bulletin Number: 1343 Bulletin Date: 11-18-2003
Component:
Power train:automatic transmission
Summary
Allison lct1000 diagnostic trouble code (dtc) p0700 and no communication with the tech 2. *tt
Bulletin Number: 00634A Bulletin Date: 11-18-2003
Component:
Engine and engine cooling:engine
Summary
Gen iii engine noise after hot soak restart. *tt
Bulletin Number: 01129A Bulletin Date: 11-18-2003
Component:
Power train
Summary
Allison lct1000 serviceability. *tt
Bulletin Number: 00938B Bulletin Date: 11-18-2003
Component:
Power train:automatic transmission:control module (tcm, pcm)
Summary
Allison lct1000 repeat transmission control module (tcm) failures with possible multiple diagnostic trouble codes (dtcs). *tt
Bulletin Number: 01275C Bulletin Date: 11-18-2003
Component:
Engine and engine cooling:engine
Summary
Some owners of 03 g-vans or 04 c/k trucks driving at high altitude with warm ambient temperatures may complain of a stall and or lack of power or running rough condition until the vehicle cools down. *tt
Bulletin Number: 00557B Bulletin Date: 11-18-2003
Component:
Power train:automatic transmission
Summary
The allison lct1000 transmissions may experience a leak from oil pump area. *tt
Bulletin Number: 1390 Bulletin Date: 11-18-2003
Component:
Equipment:electrical:radio/tape deck/cd etc.
Summary
Xm radio must be tuned to channel 1 through 66 during activation attempt. 2004 chevrolet canyon, gmc denali, gmc colorado also included. *tt
Bulletin Number: 01267B Bulletin Date: 11-18-2003
Component:
Power train:transfer case (4-wheel drive)
Summary
Service 4wd light on no codes besides u1000 codes. service vme. *tt
Bulletin Number: 1400 Bulletin Date: 11-18-2003
Component:
Engine and engine cooling:engine:gasoline:turbo-charger
Summary
6.6l duramax lb7 engines with turbocharger system whine noise. *tt
Bulletin Number: 1473 Bulletin Date: 11-18-2003
Component:
Power train:automatic transmission:control module (tcm, pcm)
Summary
Allison lct1000 diagnostic trouble code (dtc) p0700 unable to communicate with the transmission control module (tcm) using the tech 2. *tt
Bulletin Number: 11062003 Bulletin Date: 11-06-2003
Component:
Engine and engine cooling
Summary
Airflow sensor problem. *eh
Bulletin Number: 11062003 Bulletin Date: 11-06-2003
Component:
060000 engine and engine cooling
Summary
Airflow sensor problem. *eh
Bulletin Number: 30730054 Bulletin Date: 11-01-2003
Component:
Power train
Summary
Transmission fluid leaks out of vent when truck is started after a cold soak. *tt
Bulletin Number: 30308003 Bulletin Date: 11-01-2003
Component:
Suspension
Summary
Squeak noise coming from the front of the vehicle. *tt
Bulletin Number: 30730056 Bulletin Date: 11-01-2003
Component:
Power train:automatic transmission
Summary
4l60-e automatic transmission oil pump first and second design identification. *tt
Bulletin Number: 30730057 Bulletin Date: 11-01-2003
Component:
Power train:automatic transmission
Summary
Transmission fluid leak from front of transmission - torque converter housing/pump area. 2500/3500 series models. *tt
Bulletin Number: 30308003 Bulletin Date: 11-01-2003
Component:
020000 suspension
Summary
Squeak noise coming from the front of the vehicle. *tt
Bulletin Number: 30308003 Bulletin Date: 11-01-2003
Component:
020000 suspension
Summary
Squeak noise coming from the front of the vehicle. *tt
Bulletin Number: 100903 Bulletin Date: 10-09-2003
Component:
Engine and engine cooling:engine
Summary
Duramax diesel fuel in oil diagnostics revisited. gm voicemail log. this includes c4500 and 5500 trucks. *tt
Bulletin Number: 100803 Bulletin Date: 10-08-2003
Component:
Engine and engine cooling:engine
Summary
The engine diagnostic fuel leaks inside of the engine. gm voicemail log. this includes 2000 - 2004 chevroand gmc c4500 and 5500 trucks. *tt
Bulletin Number: 100803 Bulletin Date: 10-08-2003
Component:
Engine and engine cooling:engine:gasoline:turbo-charger
Summary
Excessive duramax turbocharger whine noise or possibly a performance or a fuel economy complaint. gm voicemail log. this includes 2003-2004 4500 and 5500 trucks. *tt
Bulletin Number: 030603001A Bulletin Date: 10-01-2003
Component:
Engine and engine cooling:engine
Summary
Starter cranks after key is released (normal condition). *tt
Bulletin Number: 30604045 Bulletin Date: 10-01-2003
Component:
Engine and engine cooling:engine
Summary
Revised diagnostic trouble code (dtc) p0093 or dtc p1093 diagnostic tables. *tt
Bulletin Number: 30604046 Bulletin Date: 10-01-2003
Component:
Engine and engine cooling:engine
Summary
Revised engine cranks but does not run diagnostic. *tt
Bulletin Number: 30604047 Bulletin Date: 10-01-2003
Component:
Fuel system, other
Summary
Revised fuel system diagnosis-high pressure side. *tt
Bulletin Number: 30604049 Bulletin Date: 10-01-2003
Component:
Fuel system, gasoline
Summary
Revised fuel system diagnosis pickup. *tt
Bulletin Number: 30604053 Bulletin Date: 10-01-2003
Component:
Engine and engine cooling:engine
Summary
Revised fuel injector balance test with tech 2 (manual transmission). *tt
Bulletin Number: 30604054 Bulletin Date: 10-01-2003
Component:
Engine and engine cooling:engine
Summary
Revised fuel injector balance test with tech 2 (automatic transmission). various models including 2003-2004 chevrolet kodiak and gmc topkick. *tt
Bulletin Number: 30604060 Bulletin Date: 10-01-2003
Component:
Engine and engine cooling:engine
Summary
Information on new spark plugs and gapping. various models including pontiac gto 2004. *tt
Bulletin Number: 30730053 Bulletin Date: 10-01-2003
Component:
Power train:automatic transmission
Summary
Allison automatic transmission valve body hardware changes. *tt
Bulletin Number: 030234001A Bulletin Date: 10-01-2003
Component:
Steering:linkages:tie rod assembly
Summary
Inner tie rod released for service. *tt
Bulletin Number: 10012003 Bulletin Date: 10-01-2003
Component:
Engine and engine cooling:cooling system
Summary
Blueheat coolant heater thermo top c. webasto. *mr
Bulletin Number: 030603001A Bulletin Date: 10-01-2003
Component:
061000 engine and engine cooling:engine
Summary
Starter cranks after key is released (normal condition). *tt
Bulletin Number: 030234001A Bulletin Date: 10-01-2003
Component:
017500 steering:linkages:tie rod assembly
Summary
Inner tie rod released for service. *tt
Bulletin Number: 030603001A Bulletin Date: 10-01-2003
Component:
061000 engine and engine cooling:engine
Summary
Starter cranks after key is released (normal condition). *tt
Bulletin Number: 030234001A Bulletin Date: 10-01-2003
Component:
017500 steering:linkages:tie rod assembly
Summary
Inner tie rod released for service. *tt
Bulletin Number: 30138015 Bulletin Date: 09-01-2003
Component:
Visibility:defroster/defogger system:windshield:blower
Summary
Hvac blower motor may run continuously after vehicle is turned off. *tt
Bulletin Number: 30852005 Bulletin Date: 09-01-2003
Component:
Equipment
Summary
Diagnostic information for replacement remote keyless entry (rke) transmitter inoperative - unable to synchronize. *tt
Bulletin Number: 30603008 Bulletin Date: 09-01-2003
Component:
Engine and engine cooling:engine
Summary
Avoiding oil level sensor harness damage during lower oil pan installation. *tt
Bulletin Number: 30864028 Bulletin Date: 09-01-2003
Component:
Visibility:rearview mirrors/devices:exterior
Summary
Availability of replacement parts for wide load outside rearview mirrors. *tt
Bulletin Number: 30864029 Bulletin Date: 09-01-2003
Component:
Structure:body:door
Summary
Information on removing front door trim panel to avoid breakage. *tt
Bulletin Number: 80403 Bulletin Date: 08-04-2003
Component:
Power train
Summary
This vme message applies to the valve body for the allison series 1000 transmission revised for the 2004 model year to add modulated main pressure control. this revision will provide additional transmission oil cooler flow and reduce pump
Bulletin Number: 30601023 Bulletin Date: 08-01-2003
Component:
Engine and engine cooling:engine
Summary
Higher than expected oil consumption <8500 gvw. various models including 2003-2004 chevrolet kodiak (c4500-c5500 series models)and gmc topkick (c4500-c5500 series models). *tt
Bulletin Number: 30603007 Bulletin Date: 08-01-2003
Component:
Engine and engine cooling:engine
Summary
Availability of starter motor solenoid if damaged during service. 2004 chevrolet kodiak c4500/5500 and gmc topkick c4500/5500 included. *tt
Bulletin Number: 30864022 Bulletin Date: 07-01-2003
Component:
Structure:body:door
Summary
Information on removing the front door trim panel during switch removal to avoid breakage. *tt
Bulletin Number: 30139008 Bulletin Date: 06-01-2003
Component:
Equipment:electrical:air conditioner
Summary
Changes in air conditioning compessor on/off instrument panel display symbol from 2003 to 2004 model year and synchronizing the driver and passenger set temperatures. *tt
Bulletin Number: 990730022A Bulletin Date: 06-01-2003
Component:
Power train
Summary
Shift stabilization and tow/haul mode feature for hydra-matic 4l60-e/4l65-e and 4l80-e/4l85-e transmissions. *tt
Bulletin Number: 00908C Bulletin Date: 01-01-2003
Component:
Power train:manual transmission
Summary
6.6l and manual transmission growl noise while engaging or disengaging clutch. these are c/k models. *tt
Bulletin Number: 1444 Bulletin Date: 01-01-2003
Component:
Unknown or other
Summary
Xm dealer assistance line information. *tt
Bulletin Number: 3259C Bulletin Date: 11-30--0001
Component:
Power train:automatic transmission
Summary
4l80e, 4l85e whine noise in first and second gear. *tt
Bulletin Number: 1896 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine:other fuel types:turbo-charger
Summary
6.6 lly duramax diesel engine turbocharger learn procedure. *mr
Bulletin Number: 1932 Bulletin Date: 11-30--0001
Component:
Power train:automatic transmission
Summary
Allison lct1000 dark or discolored transmission fluid with no loss of performance. *mr
Bulletin Number: 01060A Bulletin Date: 11-30--0001
Component:
Electrical system:battery
Summary
Roof beacon switch left on causing battery draw. gmc gmt 800. *mj 2005 models added. *tt
Bulletin Number: 3002 Bulletin Date: 11-30--0001
Component:
Power train
Summary
4l60e/4l65e intermittent neutral condition while accelerating from a stop or while driving. *tt 1999-2006 gm cars, light duty trucks and utilities. *tt
Bulletin Number: 3009A Bulletin Date: 11-30--0001
Component:
Suspension
Summary
Suspension vibration or frame beaming at 40 -60 mph. *mj
Bulletin Number: 3001 Bulletin Date: 11-30--0001
Component:
Power train:axle assembly
Summary
The service information and owners manual do not show a service interval for the 8.6, 9.5, 9.75, 10.5, and 11.5 inch rear axles with or without g80 (locking differential). *tt 2006 all general motors light duty trucks, vans and utilitie
Bulletin Number: 3002 Bulletin Date: 11-30--0001
Component:
Visibility:rearview mirrors/devices:exterior
Summary
Service vme - switching mirrors from power folding to power extending. *mj
Bulletin Number: 3001 Bulletin Date: 11-30--0001
Component:
Electrical system
Summary
No communication with any modules, multipe u-diagnostic trouble codes (dtcs), instrument panel cluster (ipc) warning indicators. 03-04 chevrolet all full size trucks and utilities and 03-04 gmc all full size trucks and utilities and 03-04
Bulletin Number: 3083 Bulletin Date: 11-30--0001
Component:
Power train
Summary
M74 allison lct1000 pto gear applications. *tt
Bulletin Number: 3089 Bulletin Date: 11-30--0001
Component:
Electrical system
Summary
Service engine soon light and reduced engine power with a diagnostic trouble code p1516. diagnostic trouble codes p0120, p0220, p1514, p1515, p1518 and p2135 may also be present. *tt
Bulletin Number: 3075B Bulletin Date: 11-30--0001
Component:
Electrical system
Summary
Blown mbec 1 or lbec 1 fuse. *tt
Bulletin Number: 3068 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine:gasoline:turbo-charger
Summary
Oil seepage from turbo air charge cooler hoses or hose blowing off during acceleration. possible diagnostic trouble code p0299. *tt updated 04-24-07. *kb
Bulletin Number: 3078 Bulletin Date: 11-30--0001
Component:
Suspension:front:wheel bearing
Summary
Grease leak from front hub bearing. *tt update. *tt
Bulletin Number: 3105C Bulletin Date: 11-30--0001
Component:
Power train
Summary
Ping, pop, snap, or click noise from the propeller shaft. *sc
Bulletin Number: 3134B Bulletin Date: 11-30--0001
Component:
Power train:transfer case (4-wheel drive)
Summary
Service 4wd indicator illuminated. *tc with diagnostic trouble code co327. *tt
Bulletin Number: 3156 Bulletin Date: 11-30--0001
Component:
Power train
Summary
261 transfer case drivelines growl 1100-1200 rpm. *tt
Bulletin Number: 3044 Bulletin Date: 11-30--0001
Component:
Equipment
Summary
Generation 5 onstar steering wheel control function. *tt
Bulletin Number: 3056 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt
Bulletin Number: 3078 Bulletin Date: 11-30--0001
Component:
Fuel system, other
Summary
Some 2004 full size trucks and utilities may experience a diagnostic trouble code p0442. *tt
Bulletin Number: 3161 Bulletin Date: 11-30--0001
Component:
Power train:automatic transmission
Summary
Allison lct1000 clunk noise on start in park. *eh
Bulletin Number: 3170 Bulletin Date: 11-30--0001
Component:
Power train:automatic transmission
Summary
Harsh 1-2 shift. *eh
Bulletin Number: 3137 Bulletin Date: 11-30--0001
Component:
Power train:axle assembly
Summary
Service 4wd light on and no communication with transfer case control module. *eh
Bulletin Number: 3188 Bulletin Date: 11-30--0001
Component:
Suspension:rear
Summary
Squeak noise from rear leaf springs. *eh
Bulletin Number: 3061C Bulletin Date: 11-30--0001
Component:
Electrical system
Summary
Diagnostic trouble code c0327 with or without additional diagnostic trouble codes setting. *tt
Bulletin Number: 3193 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Excessive oil consumption. *eh
Bulletin Number: 3235 Bulletin Date: 11-30--0001
Component:
Tires
Summary
20 inch wheels stop sell on 1500 crew cab with 5'8' bed. *eh
Bulletin Number: 3204 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Coolant leak at engine mount bolt. *eh
Bulletin Number: 3113 Bulletin Date: 11-30--0001
Component:
Unknown or other
Summary
No connect. gen 6 vehicles in ashe, alleghany, surry and wilkes county, nc cannot connect o onstar or emergency services. *tt
Bulletin Number: 3205 Bulletin Date: 11-30--0001
Component:
Power train
Summary
Allison lct1000 pump separator plate change disregard additional valve. *tt
Bulletin Number: 3208 Bulletin Date: 11-30--0001
Component:
Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary
Certain 2004 6.6l lly duramax diesel engines may have an issue with the high pressure fuel lines that prevent them from achieving the proper torque upon reinstallation after a repair. *tt
Bulletin Number: 3011B Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Engine oil leak at main bering side bolt. *eh
Bulletin Number: 3149 Bulletin Date: 11-30--0001
Component:
Fuel system, other
Summary
Fuel pressure regulator connector or terminal repairs. *tt
Bulletin Number: 3068B Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Turbo air charge cooler hoses oil seepage or blows off on acceleration. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh
Bulletin Number: 3212A Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Fuel leaking from body of injector. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh
Bulletin Number: 3227 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Broken #2 and #7 injector connector terminals. this also includes lly 6.6 c2 c3 c4 c5 k2 k3 d4 d5 e4 e5. *eh
Bulletin Number: 3230 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Diesel oil leak at right rear of engine. this includes lly c2 c3 c4 c5 d4 d5 e4 e5 k2 k3 models. *eh
Bulletin Number: 3238C Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Fuel injector driver circuit codes p0201 through p0208. this also includes 2004 2005 lly c2 c3 c4 c5 e4 e5 d4 d5 k2 k3 models. *eh updated *eh
Bulletin Number: 3239 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Lb7 engine vibration miss or runs rough no diagnostic trouble code. this also includes lb7 c2 c3 c4 c5 d4 d5 e4 e5 k2 k3. *eh
Bulletin Number: 3243 Bulletin Date: 11-30--0001
Component:
Power train:automatic transmission
Summary
Leak from the vent 4l80e/4l85e transmission. *eh
Bulletin Number: 3057 Bulletin Date: 11-30--0001
Component:
Steering
Summary
Service 4 wheel steer message with diagnostic trouble code c0455. *eh
Bulletin Number: 3300C Bulletin Date: 11-30--0001
Component:
Communications:horn assembly
Summary
Application of horn at horn pad inoperative. rke function for panic alarm works. *tt
Bulletin Number: 3276 Bulletin Date: 11-30--0001
Component:
Power train
Summary
4l80e output carrier thrust washer changes. *tt
Bulletin Number: 3343 Bulletin Date: 11-30--0001
Component:
Trailer hitches:fifth wheel assembly
Summary
Why the crew cab short bed (5 foot 8 inch) is not recommended for fifth wheel trailering. *tt
Bulletin Number: 3282 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
Engine overheat on vehicles equipped with rpo vyu snowplow prep package. *tt
Bulletin Number: 3292 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Diesel engine balance rates all showing zero. *eh
Bulletin Number: 3373 Bulletin Date: 11-30--0001
Component:
Air bags
Summary
Sir light on steady after bulb test and no diagnostic trouble codes (dtcs). *tt
Bulletin Number: 3386 Bulletin Date: 11-30--0001
Component:
Steering:hydraulic power assist system
Summary
Lack of steering assist or shudder during parking lot type maneuvers. *tt
Bulletin Number: 3294 Bulletin Date: 11-30--0001
Component:
Power train:axle assembly
Summary
Highway speed vibration on smooth surface. *eh
Bulletin Number: 3299 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Diesel oil leak from pcv vent tube. *eh
Bulletin Number: 3300 Bulletin Date: 11-30--0001
Component:
Power train:driveline
Summary
4wd models with noise, vibration on dry pavement. *eh
Bulletin Number: 3346 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
There has been a high percentage of no trouble found (ntf) 6.6 lly engine control modules (ecms) being returned to the warranty parts center. the no trouble found (ntf) ecms are being replaced for a specific list of diagnostic trouble code
Bulletin Number: 3464 Bulletin Date: 11-30--0001
Component:
Structure:body:door:hinge and attachments
Summary
Door hinge replacement kit. *tt
Bulletin Number: 3348 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine:gasoline:turbo-charger
Summary
Noise, service engine soon (ses) light, or low power. dealer may find turbine (exhaust side) wheel rub damage, a broken turbine shaft, or turbo bearing concern. *tt
Bulletin Number: 3351 Bulletin Date: 11-30--0001
Component:
Power train:transfer case (4-wheel drive)
Summary
Intermittent malfunction indicator lamp (mil) with diagnostic trouble code (dtc) c0374 or erratic 4wd/awd operation. *tt
Bulletin Number: 3352 Bulletin Date: 11-30--0001
Component:
Power train
Summary
Service 4wd light on with either a variety of diagnostic trouble codes or no communication with the transfer case control module. *tt
Bulletin Number: 3155 Bulletin Date: 11-30--0001
Component:
Electrical system
Summary
No shift, speedometer erratic/inoperative, p0721 c0237 p0500 c0055. *tt
Bulletin Number: 3357 Bulletin Date: 11-30--0001
Component:
Electrical system
Summary
Malfunction indicator light is on and the vehicle has a code p0706. *tt
Bulletin Number: 3232 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt
Bulletin Number: 3499 Bulletin Date: 11-30--0001
Component:
Steering:linkages:arm:idler and attachment
Summary
Steering idler arm inspection procedure. *tt
Bulletin Number: 3375 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Rough idle, service engine soon (ses)light, unstable idle, hesitation, surge or stalling. with diagnostic trouble codes p0300, p0335 or p0336. *tt
Bulletin Number: 3380 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Oil leak from the pcv vent tube. *tt
Bulletin Number: 3328A Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Surge at idle or 1100 to 1400 rpm. *eh
Bulletin Number: 3364 Bulletin Date: 11-30--0001
Component:
Power train:axle assembly
Summary
Rear axle retainer button breakage. *eh
Bulletin Number: 3504 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine:diesel
Summary
Hard start hot only after the engine has reached operating temperature and then shut off. *tt
Bulletin Number: 3497 Bulletin Date: 11-30--0001
Component:
Power train:automatic transmission
Summary
Range inhibit and/or will not move. *tt
Bulletin Number: 3671 Bulletin Date: 11-30--0001
Component:
Visibility:rearview mirrors/devices:exterior
Summary
Service vme - outside rearview mirror vibration. *tt
Bulletin Number: 3526 Bulletin Date: 11-30--0001
Component:
Power train:transfer case (4-wheel drive)
Summary
Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm. *tt
Bulletin Number: 3525 Bulletin Date: 11-30--0001
Component:
Fuel system, gasoline:fuel injection system:injectors
Summary
Service vmx - duramax injector wiring harness support bracket kit. *tt
Bulletin Number: 3562A Bulletin Date: 11-30--0001
Component:
Tires
Summary
Bridgestone dueler product information update. *tt *sc
Bulletin Number: 3556 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
Hard start or extended crank time on initial cold start when using alcohol blended fuels. *sc
Bulletin Number: 3491 Bulletin Date: 11-30--0001
Component:
Fuel system, other
Summary
Highway speed excessive smoke and fuel knock. *tt
Bulletin Number: 3427 Bulletin Date: 11-30--0001
Component:
Electrical system
Summary
Additional diagnostic information dtc p0757. *tt
Bulletin Number: 3394C Bulletin Date: 11-30--0001
Component:
Fuel system, diesel
Summary
Duramax diesel injector driver codes. misfire, rough running, and the malfunction indicator lamp (mil) / service engine soon (ses) light on. *tt
Bulletin Number: 3568A Bulletin Date: 11-30--0001
Component:
Service brakes, hydraulic
Summary
Service brake booster message. *tt
Bulletin Number: 3438A Bulletin Date: 11-30--0001
Component:
Power train:automatic transmission
Summary
Tcc surge and/or fluid contamination. *tt
Bulletin Number: 3394 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
6.6 lly injector driver codes. misfire, rough running, and the mil/ses light on. *sc
Bulletin Number: 3639 Bulletin Date: 11-30--0001
Component:
Visibility:rearview mirrors/devices
Summary
Service vme-outside rear view mirror inoperative. *sc
Bulletin Number: 3400 Bulletin Date: 11-30--0001
Component:
Fuel system, gasoline:fuel injection system:injectors
Summary
Rough idle, fuel knock or smoke while driving, combustion leak type noise, or a misfire. 6.6 lly injector knock, heavy smoke during warm up cycle. *tt
Bulletin Number: 3545 Bulletin Date: 11-30--0001
Component:
Visibility:defroster/defogger system:windshield:blower
Summary
Blower motor inoperative at low ambient temperatures. *tt
Bulletin Number: 3225A Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine:diesel
Summary
01-05 6.6 lly lb7 duramax diesel engine air filter usage. *sc
Bulletin Number: 3260 Bulletin Date: 11-30--0001
Component:
Power train
Summary
4l80e/4l85e harsh shift or slip no tcc apply. *tt
Bulletin Number: 3048A Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
Supplement to 03-06-01-024b 4.3l lu3 l35 timing chain tensioner. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. *tt
Bulletin Number: 3267 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc
Bulletin Number: 3258 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
6.6l lly engine oil leak at rear housing cover bolt. *tt
Bulletin Number: 3272 Bulletin Date: 11-30--0001
Component:
Vehicle speed control
Summary
Diesel hesitation or throttle delay. *sc
Bulletin Number: 3256A Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary
Vehicle may be brought in for service engine soon (ses) or malfunction indicator lamp (mil) light on. *tt
Bulletin Number: 3422 Bulletin Date: 11-30--0001
Component:
Visibility:rearview mirrors/devices:interior
Summary
Inaccurate outside temperature reading on inside rearview mirror. *tt
Bulletin Number: 3322 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
Incorrect o2 sensors and wiring harness causing ho2 sensor heater circuit codes p0135 p0141 p0155 p0161. *tt
Bulletin Number: 3328B Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine:diesel
Summary
Engine rpm surge at 1100 to 1400 rpm. this condition may be noticed more when towing. *tt
Bulletin Number: 3312 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
No start, hard start, loss of power, or white smoke. *tt
Bulletin Number: 3314 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine:diesel
Summary
Duramax diesel engine hard start, no start, stall of diagnostic trouble code p0093, p1093. *tt
Bulletin Number: 3105 Bulletin Date: 11-30--0001
Component:
Power train
Summary
Ping, pop, snap or click noise from the propeller shaft. *tt
Bulletin Number: 3343 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
Engine oil dipstick unseated or oil leak. *tt
Bulletin Number: 3616A Bulletin Date: 11-30--0001
Component:
Fuel system, other:storage:fuel gauge system
Summary
Fuel gauge inoperative or inaccurate, the service engine soon malfunction indicator lamp on, or front fuel tank is over filled with fuel, to the top of the filler cap. *tt
Bulletin Number: 3630A Bulletin Date: 11-30--0001
Component:
Fuel system, other:storage:fuel gauge system
Summary
Fuel gauge is inaccurate or reads empty on diesel equipped chassis cab with dual tanks. *tt
Bulletin Number: 3616 Bulletin Date: 11-30--0001
Component:
Fuel system, other:storage:fuel gauge system
Summary
Fuel gauge inaccurate/ diagnostic trouble code p0461 and or p2636/ transfer pump will not shut off. *tt
Bulletin Number: 3573 Bulletin Date: 11-30--0001
Component:
Visibility:power window devices and controls
Summary
Unwanted operation of rear windows. *tt
Bulletin Number: 3424 Bulletin Date: 11-30--0001
Component:
Power train:transfer case (4-wheel drive)
Summary
Electronic transfer case unable to complete shift. *tt
Bulletin Number: 3422 Bulletin Date: 11-30--0001
Component:
Fuel system, gasoline:fuel injection system
Summary
Duramax diesel pilot to main injection fuel knock noise. *tt
Bulletin Number: 3569 Bulletin Date: 11-30--0001
Component:
Suspension:rear:axle:non-powered axle assembly
Summary
Service vme - 8.6 inch rear axle which exhibit a gear whine condition (until december 23, 2005). *tt
Bulletin Number: 3727 Bulletin Date: 11-30--0001
Component:
Tires:pressure monitoring and regulating systems
Summary
Service tire pressure monitoring system diagnostics codes. *tt
Bulletin Number: 3639 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Oil pressure gauge reading low or near red zone. *tt
Bulletin Number: 3287B Bulletin Date: 11-30--0001
Component:
Seats:front assembly:seat heater/cooler
Summary
Heated seat inoperative or shut off in 30 seconds. diagnostic trouble codes b2435, b2440, b3606 and/or b1825 set in the drivers seat module. *tt
Bulletin Number: 3616 Bulletin Date: 11-30--0001
Component:
Fuel system, other
Summary
Service vme - 2006 duramax diesel engine fuel system components are not interchangeable with earlier year model vehicles. *tt
Bulletin Number: 3766 Bulletin Date: 11-30--0001
Component:
Visibility:defroster/defogger system:windshield:blower
Summary
Front blower inoperative stay running during low ambient temperature. *tt
Bulletin Number: 3100C Bulletin Date: 11-30--0001
Component:
Engine and engine cooling
Summary
Ses light due to dtc p0116. *tt
Bulletin Number: 3691A Bulletin Date: 11-30--0001
Component:
Visibility:defroster/defogger system:windshield:blower
Summary
Front hvac blower inoperative. *tt
Bulletin Number: 3665 Bulletin Date: 11-30--0001
Component:
Power train:transfer case (4-wheel drive)
Summary
4wd inoperative and possible dtc c0327 stored in the transfer case control module. *tt
Bulletin Number: 3673 Bulletin Date: 11-30--0001
Component:
Vehicle speed control:cruise control
Summary
Cruise control inoperative and/or malfunction indicator lamp on with diagnostic trouble code p0833 stored. the condition may not be able to be duplicated by the dealer yet the consumer may have a repeat concern. *ak
Bulletin Number: 3691B Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
Generation iii v8 engine piston repairs. *tt
Bulletin Number: 3401 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine:gasoline:turbo-charger
Summary
Turbocharger oil feed line kinked or restricted. *tt
Bulletin Number: 3870 Bulletin Date: 11-30--0001
Component:
Power train:clutch assembly
Summary
Clutch pedal fade or clutch will not disengage typically when towing. *tt
Bulletin Number: 3562 Bulletin Date: 11-30--0001
Component:
Tires
Summary
Bridgestone dueler product information update. *kb
Bulletin Number: 3190 Bulletin Date: 11-30--0001
Component:
Electrical system
Summary
Unable to locate emergency light relay and/or blunt cut wires. *kb
Bulletin Number: 4179 Bulletin Date: 11-30--0001
Component:
Air bags
Summary
Dual stage passenger air bag used in single stage application. *kb
Bulletin Number: 3136 Bulletin Date: 11-30--0001
Component:
Power train:manual transmission
Summary
Slip condition in 2nd, 3rd, or 4th. damaged 2-4 or 3-4 clutch. *kb updated 10/31/07. *nj
Bulletin Number: 4231 Bulletin Date: 11-30--0001
Component:
Engine and engine cooling:engine
Summary
Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb
Bulletin Number: 3425 Bulletin Date: 11-30--0001
Component:
Tires
Summary
Unable to program tire size in ebcm/vses. *kb
Bulletin Number: 3568 Bulletin Date: 11-30--0001
Component:
Service brakes, air
Summary
Service brake booster message. *kb
Bulletin Number: 4365 Bulletin Date: 11-30--0001
Component:
Interior lighting
Summary
Ipc backlighting inoperative tbc 2a fuse open. *kb
Bulletin Number: 4030 Bulletin Date: 11-30--0001
Component:
Power train:axle assembly
Summary
New design front axle side bearing adjusters. *kb
Bulletin Number: 4144 Bulletin Date: 11-30--0001
Component:
Power train:manual transmission
Summary
Allison lct1000 harsh 3-2, 2-1 downshift, and abs may activate. *kb
Bulletin Number: 3075 Bulletin Date: 11-30--0001
Component:
Electrical system:fuses and circuit breakers
Summary
Blown mbec 1 or lbec 1 fuse. *kb
Bulletin Number: 4486 Bulletin Date: 11-30--0001
Component:
Digital instrument panel
Summary
One of the following concerns when programming the mileage or the hours into an exchange instrument panel cluster that is received from an electronic service center (esc). *nj
Bulletin Number: 3002 Bulletin Date: 11-30--0001
Component:
100000 power train
Summary
4l60e/4l65e intermittent neutral condition while accelerating from a stop or while driving. *tt 1999-2006 gm cars, light duty trucks and utilities. *tt
Bulletin Number: 3009A Bulletin Date: 11-30--0001
Component:
020000 suspension
Summary
Suspension vibration or frame beaming at 40 -60 mph. *mj
Bulletin Number: 3001 Bulletin Date: 11-30--0001
Component:
106000 power train:axle assembly
Summary
The service information and owners manual do not show a service interval for the 8.6, 9.5, 9.75, 10.5, and 11.5 inch rear axles with or without g80 (locking differential). *tt 2006 all general motors light duty trucks, vans and utilitie
Bulletin Number: 3002 Bulletin Date: 11-30--0001
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary
Service vme - switching mirrors from power folding to power extending. *mj
Bulletin Number: 3001 Bulletin Date: 11-30--0001
Component:
110000 electrical system
Summary
No communication with any modules, multipe u-diagnostic trouble codes (dtcs), instrument panel cluster (ipc) warning indicators. 03-04 chevrolet all full size trucks and utilities and 03-04 gmc all full size trucks and utilities and 03-04
Bulletin Number: 3083 Bulletin Date: 11-30--0001
Component:
100000 power train
Summary
M74 allison lct1000 pto gear applications. *tt
Bulletin Number: 3089 Bulletin Date: 11-30--0001
Component:
110000 electrical system
Summary
Service engine soon light and reduced engine power with a diagnostic trouble code p1516. diagnostic trouble codes p0120, p0220, p1514, p1515, p1518 and p2135 may also be present. *tt
Bulletin Number: 3075B Bulletin Date: 11-30--0001
Component:
110000 electrical system
Summary
Blown mbec 1 or lbec 1 fuse. *tt
Bulletin Number: 3068 Bulletin Date: 11-30--0001
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary
Oil seepage from turbo air charge cooler hoses or hose blowing off during acceleration. possible diagnostic trouble code p0299. *tt updated 04-24-07. *kb
Bulletin Number: 3078 Bulletin Date: 11-30--0001
Component:
021600 suspension:front:wheel bearing
Summary
Grease leak from front hub bearing. *tt update. *tt
Bulletin Number: 3105C Bulletin Date: 11-30--0001
Component:
100000 power train
Summary
Ping, pop, snap, or click noise from the propeller shaft. *sc
Bulletin Number: 3134B Bulletin Date: 11-30--0001
Component:
104000 power train:transfer case (4-wheel drive)
Summary
Service 4wd indicator illuminated. *tc with diagnostic trouble code co327. *tt
Bulletin Number: 3156 Bulletin Date: 11-30--0001
Component:
100000 power train
Summary
261 transfer case drivelines growl 1100-1200 rpm. *tt
Bulletin Number: 3044 Bulletin Date: 11-30--0001
Component:
350000 equipment
Summary
Generation 5 onstar steering wheel control function. *tt
Bulletin Number: 3056 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt
Bulletin Number: 3078 Bulletin Date: 11-30--0001
Component:
090000 fuel system, other
Summary
Some 2004 full size trucks and utilities may experience a diagnostic trouble code p0442. *tt
Bulletin Number: 3161 Bulletin Date: 11-30--0001
Component:
103000 power train:automatic transmission
Summary
Allison lct1000 clunk noise on start in park. *eh
Bulletin Number: 3170 Bulletin Date: 11-30--0001
Component:
103000 power train:automatic transmission
Summary
Harsh 1-2 shift. *eh
Bulletin Number: 3137 Bulletin Date: 11-30--0001
Component:
106000 power train:axle assembly
Summary
Service 4wd light on and no communication with transfer case control module. *eh
Bulletin Number: 3188 Bulletin Date: 11-30--0001
Component:
022000 suspension:rear
Summary
Squeak noise from rear leaf springs. *eh
Bulletin Number: 3061C Bulletin Date: 11-30--0001
Component:
110000 electrical system
Summary
Diagnostic trouble code c0327 with or without additional diagnostic trouble codes setting. *tt
Bulletin Number: 3193 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Excessive oil consumption. *eh
Bulletin Number: 3235 Bulletin Date: 11-30--0001
Component:
190000 tires
Summary
20 inch wheels stop sell on 1500 crew cab with 5'8' bed. *eh
Bulletin Number: 3204 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Coolant leak at engine mount bolt. *eh
Bulletin Number: 3113 Bulletin Date: 11-30--0001
Component:
980000 unknown or other
Summary
No connect. gen 6 vehicles in ashe, alleghany, surry and wilkes county, nc cannot connect o onstar or emergency services. *tt
Bulletin Number: 3205 Bulletin Date: 11-30--0001
Component:
100000 power train
Summary
Allison lct1000 pump separator plate change disregard additional valve. *tt
Bulletin Number: 3208 Bulletin Date: 11-30--0001
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary
Certain 2004 6.6l lly duramax diesel engines may have an issue with the high pressure fuel lines that prevent them from achieving the proper torque upon reinstallation after a repair. *tt
Bulletin Number: 3011B Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Engine oil leak at main bering side bolt. *eh
Bulletin Number: 3149 Bulletin Date: 11-30--0001
Component:
090000 fuel system, other
Summary
Fuel pressure regulator connector or terminal repairs. *tt
Bulletin Number: 3068B Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Turbo air charge cooler hoses oil seepage or blows off on acceleration. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh
Bulletin Number: 3212A Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Fuel leaking from body of injector. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh
Bulletin Number: 3227 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Broken #2 and #7 injector connector terminals. this also includes lly 6.6 c2 c3 c4 c5 k2 k3 d4 d5 e4 e5. *eh
Bulletin Number: 3230 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Diesel oil leak at right rear of engine. this includes lly c2 c3 c4 c5 d4 d5 e4 e5 k2 k3 models. *eh
Bulletin Number: 3238C Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Fuel injector driver circuit codes p0201 through p0208. this also includes 2004 2005 lly c2 c3 c4 c5 e4 e5 d4 d5 k2 k3 models. *eh updated *eh
Bulletin Number: 3239 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Lb7 engine vibration miss or runs rough no diagnostic trouble code. this also includes lb7 c2 c3 c4 c5 d4 d5 e4 e5 k2 k3. *eh
Bulletin Number: 3243 Bulletin Date: 11-30--0001
Component:
103000 power train:automatic transmission
Summary
Leak from the vent 4l80e/4l85e transmission. *eh
Bulletin Number: 3057 Bulletin Date: 11-30--0001
Component:
010000 steering
Summary
Service 4 wheel steer message with diagnostic trouble code c0455. *eh
Bulletin Number: 3300C Bulletin Date: 11-30--0001
Component:
341000 communications:horn assembly
Summary
Application of horn at horn pad inoperative. rke function for panic alarm works. *tt
Bulletin Number: 3276 Bulletin Date: 11-30--0001
Component:
100000 power train
Summary
4l80e output carrier thrust washer changes. *tt
Bulletin Number: 3343 Bulletin Date: 11-30--0001
Component:
211000 trailer hitches:fifth wheel assembly
Summary
Why the crew cab short bed (5 foot 8 inch) is not recommended for fifth wheel trailering. *tt
Bulletin Number: 3282 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
Engine overheat on vehicles equipped with rpo vyu snowplow prep package. *tt
Bulletin Number: 3292 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Diesel engine balance rates all showing zero. *eh
Bulletin Number: 3373 Bulletin Date: 11-30--0001
Component:
140000 air bags
Summary
Sir light on steady after bulb test and no diagnostic trouble codes (dtcs). *tt
Bulletin Number: 3386 Bulletin Date: 11-30--0001
Component:
015000 steering:hydraulic power assist system
Summary
Lack of steering assist or shudder during parking lot type maneuvers. *tt
Bulletin Number: 3294 Bulletin Date: 11-30--0001
Component:
106000 power train:axle assembly
Summary
Highway speed vibration on smooth surface. *eh
Bulletin Number: 3299 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Diesel oil leak from pcv vent tube. *eh
Bulletin Number: 3300 Bulletin Date: 11-30--0001
Component:
105000 power train:driveline
Summary
4wd models with noise, vibration on dry pavement. *eh
Bulletin Number: 3346 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
There has been a high percentage of no trouble found (ntf) 6.6 lly engine control modules (ecms) being returned to the warranty parts center. the no trouble found (ntf) ecms are being replaced for a specific list of diagnostic trouble code
Bulletin Number: 3464 Bulletin Date: 11-30--0001
Component:
162310 structure:body:door:hinge and attachments
Summary
Door hinge replacement kit. *tt
Bulletin Number: 3348 Bulletin Date: 11-30--0001
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary
Noise, service engine soon (ses) light, or low power. dealer may find turbine (exhaust side) wheel rub damage, a broken turbine shaft, or turbo bearing concern. *tt
Bulletin Number: 3351 Bulletin Date: 11-30--0001
Component:
104000 power train:transfer case (4-wheel drive)
Summary
Intermittent malfunction indicator lamp (mil) with diagnostic trouble code (dtc) c0374 or erratic 4wd/awd operation. *tt
Bulletin Number: 3352 Bulletin Date: 11-30--0001
Component:
100000 power train
Summary
Service 4wd light on with either a variety of diagnostic trouble codes or no communication with the transfer case control module. *tt
Bulletin Number: 3155 Bulletin Date: 11-30--0001
Component:
110000 electrical system
Summary
No shift, speedometer erratic/inoperative, p0721 c0237 p0500 c0055. *tt
Bulletin Number: 3357 Bulletin Date: 11-30--0001
Component:
110000 electrical system
Summary
Malfunction indicator light is on and the vehicle has a code p0706. *tt
Bulletin Number: 3232 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt
Bulletin Number: 3499 Bulletin Date: 11-30--0001
Component:
017300 steering:linkages:arm:idler and attachment
Summary
Steering idler arm inspection procedure. *tt
Bulletin Number: 3375 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Rough idle, service engine soon (ses)light, unstable idle, hesitation, surge or stalling. with diagnostic trouble codes p0300, p0335 or p0336. *tt
Bulletin Number: 3380 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Oil leak from the pcv vent tube. *tt
Bulletin Number: 3328A Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Surge at idle or 1100 to 1400 rpm. *eh
Bulletin Number: 3364 Bulletin Date: 11-30--0001
Component:
106000 power train:axle assembly
Summary
Rear axle retainer button breakage. *eh
Bulletin Number: 3504 Bulletin Date: 11-30--0001
Component:
061200 engine and engine cooling:engine:diesel
Summary
Hard start hot only after the engine has reached operating temperature and then shut off. *tt
Bulletin Number: 3497 Bulletin Date: 11-30--0001
Component:
103000 power train:automatic transmission
Summary
Range inhibit and/or will not move. *tt
Bulletin Number: 3671 Bulletin Date: 11-30--0001
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary
Service vme - outside rearview mirror vibration. *tt
Bulletin Number: 3526 Bulletin Date: 11-30--0001
Component:
104000 power train:transfer case (4-wheel drive)
Summary
Intermittent service 4wd light comes on with diagnostic trouble code (dtc) c0306 or c0308 stored in tccm. *tt
Bulletin Number: 3525 Bulletin Date: 11-30--0001
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary
Service vmx - duramax injector wiring harness support bracket kit. *tt
Bulletin Number: 3562A Bulletin Date: 11-30--0001
Component:
190000 tires
Summary
Bridgestone dueler product information update. *tt *sc
Bulletin Number: 3556 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
Hard start or extended crank time on initial cold start when using alcohol blended fuels. *sc
Bulletin Number: 3491 Bulletin Date: 11-30--0001
Component:
090000 fuel system, other
Summary
Highway speed excessive smoke and fuel knock. *tt
Bulletin Number: 3427 Bulletin Date: 11-30--0001
Component:
110000 electrical system
Summary
Additional diagnostic information dtc p0757. *tt
Bulletin Number: 3394C Bulletin Date: 11-30--0001
Component:
080000 fuel system, diesel
Summary
Duramax diesel injector driver codes. misfire, rough running, and the malfunction indicator lamp (mil) / service engine soon (ses) light on. *tt
Bulletin Number: 3568A Bulletin Date: 11-30--0001
Component:
030000 service brakes, hydraulic
Summary
Service brake booster message. *tt
Bulletin Number: 3438A Bulletin Date: 11-30--0001
Component:
103000 power train:automatic transmission
Summary
Tcc surge and/or fluid contamination. *tt
Bulletin Number: 3394 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
6.6 lly injector driver codes. misfire, rough running, and the mil/ses light on. *sc
Bulletin Number: 3639 Bulletin Date: 11-30--0001
Component:
135000 visibility:rearview mirrors/devices
Summary
Service vme-outside rear view mirror inoperative. *sc
Bulletin Number: 3400 Bulletin Date: 11-30--0001
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary
Rough idle, fuel knock or smoke while driving, combustion leak type noise, or a misfire. 6.6 lly injector knock, heavy smoke during warm up cycle. *tt
Bulletin Number: 3545 Bulletin Date: 11-30--0001
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary
Blower motor inoperative at low ambient temperatures. *tt
Bulletin Number: 3225A Bulletin Date: 11-30--0001
Component:
061200 engine and engine cooling:engine:diesel
Summary
01-05 6.6 lly lb7 duramax diesel engine air filter usage. *sc
Bulletin Number: 3260 Bulletin Date: 11-30--0001
Component:
100000 power train
Summary
4l80e/4l85e harsh shift or slip no tcc apply. *tt
Bulletin Number: 3048A Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
Supplement to 03-06-01-024b 4.3l lu3 l35 timing chain tensioner. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. *tt
Bulletin Number: 3267 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc
Bulletin Number: 3258 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
6.6l lly engine oil leak at rear housing cover bolt. *tt
Bulletin Number: 3272 Bulletin Date: 11-30--0001
Component:
180000 vehicle speed control
Summary
Diesel hesitation or throttle delay. *sc
Bulletin Number: 3256A Bulletin Date: 11-30--0001
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary
Vehicle may be brought in for service engine soon (ses) or malfunction indicator lamp (mil) light on. *tt
Bulletin Number: 3422 Bulletin Date: 11-30--0001
Component:
135100 visibility:rearview mirrors/devices:interior
Summary
Inaccurate outside temperature reading on inside rearview mirror. *tt
Bulletin Number: 3322 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
Incorrect o2 sensors and wiring harness causing ho2 sensor heater circuit codes p0135 p0141 p0155 p0161. *tt
Bulletin Number: 3328B Bulletin Date: 11-30--0001
Component:
061200 engine and engine cooling:engine:diesel
Summary
Engine rpm surge at 1100 to 1400 rpm. this condition may be noticed more when towing. *tt
Bulletin Number: 3312 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
No start, hard start, loss of power, or white smoke. *tt
Bulletin Number: 3314 Bulletin Date: 11-30--0001
Component:
061200 engine and engine cooling:engine:diesel
Summary
Duramax diesel engine hard start, no start, stall of diagnostic trouble code p0093, p1093. *tt
Bulletin Number: 3105 Bulletin Date: 11-30--0001
Component:
100000 power train
Summary
Ping, pop, snap or click noise from the propeller shaft. *tt
Bulletin Number: 3343 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
Engine oil dipstick unseated or oil leak. *tt
Bulletin Number: 3616A Bulletin Date: 11-30--0001
Component:
091200 fuel system, other:storage:fuel gauge system
Summary
Fuel gauge inoperative or inaccurate, the service engine soon malfunction indicator lamp on, or front fuel tank is over filled with fuel, to the top of the filler cap. *tt
Bulletin Number: 3630A Bulletin Date: 11-30--0001
Component:
091200 fuel system, other:storage:fuel gauge system
Summary
Fuel gauge is inaccurate or reads empty on diesel equipped chassis cab with dual tanks. *tt
Bulletin Number: 3616 Bulletin Date: 11-30--0001
Component:
091200 fuel system, other:storage:fuel gauge system
Summary
Fuel gauge inaccurate/ diagnostic trouble code p0461 and or p2636/ transfer pump will not shut off. *tt
Bulletin Number: 3573 Bulletin Date: 11-30--0001
Component:
133000 visibility:power window devices and controls
Summary
Unwanted operation of rear windows. *tt
Bulletin Number: 3424 Bulletin Date: 11-30--0001
Component:
104000 power train:transfer case (4-wheel drive)
Summary
Electronic transfer case unable to complete shift. *tt
Bulletin Number: 3422 Bulletin Date: 11-30--0001
Component:
073000 fuel system, gasoline:fuel injection system
Summary
Duramax diesel pilot to main injection fuel knock noise. *tt
Bulletin Number: 3569 Bulletin Date: 11-30--0001
Component:
022520 suspension:rear:axle:non-powered axle assembly
Summary
Service vme - 8.6 inch rear axle which exhibit a gear whine condition (until december 23, 2005). *tt
Bulletin Number: 3727 Bulletin Date: 11-30--0001
Component:
199000 tires:pressure monitoring and regulating systems
Summary
Service tire pressure monitoring system diagnostics codes. *tt
Bulletin Number: 3639 Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Oil pressure gauge reading low or near red zone. *tt
Bulletin Number: 3287B Bulletin Date: 11-30--0001
Component:
221700 seats:front assembly:seat heater/cooler
Summary
Heated seat inoperative or shut off in 30 seconds. diagnostic trouble codes b2435, b2440, b3606 and/or b1825 set in the drivers seat module. *tt
Bulletin Number: 3616 Bulletin Date: 11-30--0001
Component:
090000 fuel system, other
Summary
Service vme - 2006 duramax diesel engine fuel system components are not interchangeable with earlier year model vehicles. *tt
Bulletin Number: 3766 Bulletin Date: 11-30--0001
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary
Front blower inoperative stay running during low ambient temperature. *tt
Bulletin Number: 3100C Bulletin Date: 11-30--0001
Component:
060000 engine and engine cooling
Summary
Ses light due to dtc p0116. *tt
Bulletin Number: 3691A Bulletin Date: 11-30--0001
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary
Front hvac blower inoperative. *tt
Bulletin Number: 3665 Bulletin Date: 11-30--0001
Component:
104000 power train:transfer case (4-wheel drive)
Summary
4wd inoperative and possible dtc c0327 stored in the transfer case control module. *tt
Bulletin Number: 3673 Bulletin Date: 11-30--0001
Component:
185000 vehicle speed control:cruise control
Summary
Cruise control inoperative and/or malfunction indicator lamp on with diagnostic trouble code p0833 stored. the condition may not be able to be duplicated by the dealer yet the consumer may have a repeat concern. *ak
Bulletin Number: 3691B Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
Generation iii v8 engine piston repairs. *tt
Bulletin Number: 3401 Bulletin Date: 11-30--0001
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary
Turbocharger oil feed line kinked or restricted. *tt
Bulletin Number: 3870 Bulletin Date: 11-30--0001
Component:
101000 power train:clutch assembly
Summary
Clutch pedal fade or clutch will not disengage typically when towing. *tt
Bulletin Number: 3562 Bulletin Date: 11-30--0001
Component:
190000 tires
Summary
Bridgestone dueler product information update. *kb
Bulletin Number: 3190 Bulletin Date: 11-30--0001
Component:
110000 electrical system
Summary
Unable to locate emergency light relay and/or blunt cut wires. *kb
Bulletin Number: 4179 Bulletin Date: 11-30--0001
Component:
140000 air bags
Summary
Dual stage passenger air bag used in single stage application. *kb
Bulletin Number: 3136 Bulletin Date: 11-30--0001
Component:
102000 power train:manual transmission
Summary
Slip condition in 2nd, 3rd, or 4th. damaged 2-4 or 3-4 clutch. *kb updated 10/31/07. *nj
Bulletin Number: 4231 Bulletin Date: 11-30--0001
Component:
061000 engine and engine cooling:engine
Summary
Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb
Bulletin Number: 3425 Bulletin Date: 11-30--0001
Component:
190000 tires
Summary
Unable to program tire size in ebcm/vses. *kb
Bulletin Number: 3568 Bulletin Date: 11-30--0001
Component:
040000 service brakes, air
Summary
Service brake booster message. *kb
Bulletin Number: 4365 Bulletin Date: 11-30--0001
Component:
330000 interior lighting
Summary
Ipc backlighting inoperative tbc 2a fuse open. *kb
Bulletin Number: 4030 Bulletin Date: 11-30--0001
Component:
106000 power train:axle assembly
Summary
New design front axle side bearing adjusters. *kb
Bulletin Number: 4144 Bulletin Date: 11-30--0001
Component:
102000 power train:manual transmission
Summary
Allison lct1000 harsh 3-2, 2-1 downshift, and abs may activate. *kb
Bulletin Number: 3075 Bulletin Date: 11-30--0001
Component:
115000 electrical system:fuses and circuit breakers
Summary
Blown mbec 1 or lbec 1 fuse. *kb
Bulletin Number: 4486 Bulletin Date: 11-30--0001
Component:
117000 digital instrument panel
Summary
One of the following concerns when programming the mileage or the hours into an exchange instrument panel cluster that is received from an electronic service center (esc). *nj
Recall Number: 09E025000 Recall Date: 05-11-2009 Affected Vehicles: 42,540
Component:
Exterior lighting:headlights
Summary:
"dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, ""lamps, reflective devices, and associated equipment."" these lamps do not contain the required amber side reflectors."
Consequence:
Decreased lighting visibility may result in a vehicle crash.
How to Fix:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Recall Number: 07E066000 Recall Date: 08-28-2007 Affected Vehicles: 175
Component:
Equipment:electrical
Summary:
Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence:
If the trailer lights are not working properly, a vehicle crash can occur.
How to Fix:
All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Recall Number: 06V289000 Recall Date: 08-03-2006 Affected Vehicles: 38,439
Component:
Engine and engine cooling
Summary:
On certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper.
Consequence:
If the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire.
How to Fix:
Dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463.
Recall Number: 05V163000 Recall Date: 04-22-2005 Affected Vehicles: 1,359,824
Component:
Seat belts:rear
Summary:
On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. in addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
Consequence:
A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
How to Fix:
Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. the recall began on july 21, 2005. owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493.
Recall Number: 05V161000 Recall Date: 04-22-2005 Affected Vehicles: 90,242
Component:
Parking brake
Summary:
On certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.
Consequence:
If the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash.
How to Fix:
Dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. on vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. the recall began on july 29, 2005. owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Recall Number: 05V043000 Recall Date: 02-08-2005 Affected Vehicles: 77,411
Component:
Service brakes, hydraulic
Summary:
Certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions.
Consequence:
If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning.
How to Fix:
Dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493.
Recall Number: 04V225000 Recall Date: 05-11-2004 Affected Vehicles: 736
Component:
Seat belts:front:anchorage
Summary:
Certain extended and regular cab pickup trucks and cargo vans converted to compressed natural gas (cng) fail to conform to the requirements of federal motor vehicle safety standard no. 225, 'child restraint anchorage systems.' these vehicles have one seating position, the center rear seat, equipped with child restraint lower anchorages.
Consequence:
The standard requires child seat lower anchorages in two seating positions for vehicles with three rear seating positions. the standard cab and cargo van vehicles, which only have front seating positions, have an air bag off switch to disable the front passenger air bag and do not have child restraint lower anchorages in the passenger seat. the standard requires passenger seat child seat lower anchorages in vehicles with an air bag off switch. however, the standard does not require vehicles with only front seating positions to have lower anchorage provisions if the vehicle is not equipped with an air bag off switch.
How to Fix:
To bring the standard cab and cargo van vehicles into compliance, dealers will inject epoxy into the air bag off switch to prevent air bag activation, relocate the switch behind the instrument panel and then install a cover over the resulting opening. the sun visor label and owner's manual will also be changed. the correction for the extended cab vehicle will consist of changing the front passenger seat to a seat that has child restraint lower anchorages. the recall began on september 9, 2004. owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Recall Number: 04E022000 Recall Date: 03-23-2004 Affected Vehicles: 8,000
Component:
Equipment
Summary:
Aftermarket pickup truck over-the-rail bedliners manufactured for installation on 1999-2004 chevrolet silverado and gmc sierra pickup trucks. the toggle wing assembly used to attach the bedliner to the truck bed is not engaging fully in the stake pocket of the pickup truck.
Consequence:
The bedliner can become detached from the pickup while it is motion, possibly endangering following motorists or pedestrians.
How to Fix:
Durakon will issue a press release in attempt to notify customers that could have purchased the defective bedliner. if you purchased either a durakon allstar of patriot overrail bedliner since august 1, 2003, for 1999 to 2004 chevrolet silverado or gmc sierra trucks, or purchased one of these pickup trucks with either brand bedliner already installed, you should return to an authorized durakon dealer so that the bedliner can be inspected and, if necessary, repaired with a newly designed toggle wing fastening system, or if required, replaced with a new bedliner free of charge. please call the durakon hotline at 1-800-933-4200 to find the nearest authorized durakon dealer.
Recall Number: 04V129000 Recall Date: 03-17-2004 Affected Vehicles: 3,662,211
Component:
Structure:body:tailgate:hinge and attachments
Summary:
On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. if both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
Consequence:
Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. on vehicles that have had the bumper removed, the tailgate may drop even lower. additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture.
How to Fix:
Dealers will replace the cables. interim owner notification began on april 7, 20004. the recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number.
Recall Number: 04V045000 Recall Date: 02-04-2004 Affected Vehicles: 68,875
Component:
Service brakes, hydraulic
Summary:
Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
Consequence:
Consequently, the valve o-ring seal may fracture. steering efforts may be slightly increased while braking or parking. under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
How to Fix:
Dealers are to replace the hydro-boost relief valve. the recall began on june 18, 2004. owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376.
Need A Repair Shop?
Find local automotive repair shops in your area.
Home - Privacy Policy - Terms and Conditions - Copyright 2010-2017 Helpforcars.net
AutoCodes.com - HelpForCars.net - Infinitihelp.com - Nissanhelp.com